《氯化橡胶云铁中间漆》由会员分享，可在线阅读，更多相关《氯化橡胶云铁中间漆（4页珍藏版）》请在金锄头文库上搜索。
1、氯化橡胶云铁中间漆氯化橡胶云铁中间漆Intended Uses用途用途适用于船舶、煤气罐、海港码头、海上钢结构飞溅区、石油化工设备外壁，管架 及其他钢结构防蚀、也可涂在混凝土物件作为保护层，由于云母氧化铁为鳞片状 颜料，具有独特的屏蔽性能，颜料能定向平行重叠排列，形似“鱼鳞”一般的搭接结 构，因此涂膜具有优良的防锈、防潮、耐化学腐蚀性能。Apply to vessels, gas cylinders, the harbor terminal, maritime steel splash zone, the outer wall of petrochemical equipment, aircr
2、aft and other steel pipe corrosion can also be applied to the concrete object as a protective layer, as a result of micaceous iron oxide pigments for the scale-like, with shielding unique, pigments can overlap with parallel orientation, the shape of “fish scale“ structure of overlap in general, it h
3、as an excellent anti-rust coating, moisture resistance, chemical corrosion. ProductDescription产品简介产品简介灰黑色，底漆或中涂漆Grey black, primer or intermediate coating Volume Solids 固体份40%Dry Film Thickness 干膜厚度70microns equivalent to 175 microns of wet film 70 微米相当于 175 微米湿膜厚 Theoretical Coverage 理论涂布率4.1 m2 /K
4、g 4.1 平方米/公斤ProductInformation产品数据产品数据 Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗 Mix Radio 混合比One pack 单罐装 Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or Roller 涂刷或辊涂 Recommended 推荐采用Conventional Spray 传统喷涂 Not Recommended 不推荐使用Thinner 稀释剂 C001Application Details施
5、工详述施工详述Cleaner 油漆设备清洗剂 C001Pot Life 使用期 Not limit 不限制 Storage 贮存期 One year 一年 Over coating Interval覆涂间隔SubstrateTemperature 底材温度Touch Dry表干（H）Hard Dry硬干(H）Mix 最短Max 最长 Drying time 干燥时间250.580 24 hour 小时24 8 hour 小时30 6 hour 小时Not limit 不限Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size
6、 包装规格 25Kg in 20 liter container 25 公斤装于 20 公升容 器中 Flash Point 闪点 31 高于 23Storage andHandling贮存与管理贮存与管理Specific Gravity 比重 Approx1.4 Kg/L 大约 1.4 公斤/公升Specification and Surface preparation技术要求及表技术要求及表 面处理面处理Steel surface to be painted should be shot or grit blasted to Swedish Standard Sa2.5 surfaceOv
7、er shop primer should be rust-removed again to reach Swedish Standard St3施工钢材表面需经抛丸或喷砂处理除锈达瑞典标准 Sa2.5 级，涂有车间底漆钢材 表面则需要经再次除锈，达到瑞典的手工除锈标准 St3Limitations限制限制Preceding coat: Workshop epoxy zinc-rich primer, epoxy zinc primer workshop, iron oxide red epoxy paint shop, paint shop inorganic acid, aluminum
8、chloride Antirust Paint rubber, chlorinated rubber-type iron oxide red antirust thick slurry Chatham.Subsequent coat: Thick slurry chlorinated rubber-based paint, acrylic pulp Antirust Paint thick long-lasting, thick rubber chloride-based paste, such as long-term Antirust Paint, etc.前道配套涂料：环氧富锌车间底漆，
9、环氧锌粉车间底漆、环氧铁红车间底漆、无 机硅酸车间底漆、氯化橡胶铝粉防锈漆、氯化橡胶铁红厚浆型防锈漆等。后道配套涂料：氯化橡胶厚浆型面漆、丙烯酸长效厚浆防锈漆、氯化橡胶厚浆型 长效防锈漆等。SafetyPrecautions安全措施安全措施The product must be used in painting area by professionals. When painting , please be sure to refer to Product Data Sheet and MSDS. Consult our company if consumers could not compl
10、etely understand the precautions for safety and health when applying the product.The product is a kind of solvent-based paint. In order to avoid the accident or dangerous occurrence, minimal safety precaution, as follow, should be down.The paint contains volatile solvent and it is flammable, So must
11、 keep away from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid product sparks. Enough ventilation is necessary at application si
12、tes. In order to remove any danger of explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg solvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin and eye contact
13、with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If accidental skin contact with the product, please use fresh water and soap or an appropriate industrial cleaning agents thoroughly cleansed. In case
14、of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended to wear face shields to prevent inhalation of paint mist and harmful gases.Especially in poorly ventilated environment, it is more necessary.Finally, be ha
15、ndled with care so as not to waste paint barrels of pollution of the environment.NOTICE: If consumers have not taken effective safety precautions (Refer to the specification), our company will NOT be responsible for any accident.本产品必须由专业人员在工业场所使用。使用时请务必参照本说明书以及相关 健康安全手册。若客户在使用本产品前,未能详细了解本产品的相关健康安全知 识,请与本公司人员联系。该涂料为溶剂型涂料，为避免事故或危险发生，应采取最低限度的安全措施如下：此涂料为易燃物,并含有挥发性易燃溶
