《2006款三菱蒙特罗车轮与轮胎维修手册（英文版）》由会员分享，可在线阅读，更多相关《2006款三菱蒙特罗车轮与轮胎维修手册（英文版）（98页珍藏版）》请在金锄头文库上搜索。
1、31-1GROUP 31WHEEL AND TIRECONTENTSGENERAL DESCRIPTION. . . . . . . . . 31-2TIRE PRESSURE MONITORING SYSTEM (TPMS) SERVICE PRECAUTIONS . . 31-9WHEEL AND TIRE DIAGNOSIS . . . . 31-10DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . . . . 31-10WHEEL BALANCE ACCURACY . . . . . . . . 31-11TIRE PRESSURE
2、 MONITORING SYSTEM (TPMS) DIAGNOSIS . . . . . . . . . . . . . 31-14INTRODUCTION TO DIAGNOSIS . . . . . . . 31-14TPMS TROUBLESHOOTING STRATEGY. 31-14TPMS DIAGNOSTIC FUNCTION . . . . . . . . 31-15TPMS WARNING LIGHT CHECK. . . . . . . . 31-18DIAGNOSTIC TROUBLE CODE CHART. . 31-19TPMS DIAGNOSTIC TROUBLE
3、 CODE PROCEDURES. . . . . . . . . . . . . . . . . . . . . . 31-20TPMS SYMPTOM CHART . . . . . . . . . . . . . 31-47TPMS SYMPTOM PROCEDURES. . . . . . . 31-48TPMS SERVICE DATA LIST . . . . . . . . . . . 31-81TPMS ACTUATOR TEST . . . . . . . . . . . . . . 31-82TPMS SPECIAL FUNCTION DATA LIST . . 31-82
4、CHECK AT TPMS RECEIVER . . . . . . . . . . 31-83SPECIAL TOOLS. . . . . . . . . . . . . . . . 31-84ON-VEHICLE SERVICE . . . . . . . . . . . 31-85TIRE INFLATION PRESSURE CHECK . . . 31-85TIRE WEAR CHECK . . . . . . . . . . . . . . . . . . 31-85WHEEL RUNOUT CHECK . . . . . . . . . . . . . 31-85TPMS SPE
5、CIAL FUNCTION. . . . . . . . . . . . 31-86TIRE PRESSURE SENSOR ID REGISTRATION . . . . . . . . . . . . . . . . . . . . . 31-86TIRE PRESSURE SENSOR ID CHECK . . . 31-88TIRE PRESSURE SENSOR CHECK . . . . . 31-89WHEEL AND TIRE . . . . . . . . . . . . . . . 31-90INSTALLATION SERVICE POINT . . . . . . .
6、31-90WHEEL AND TIRE REPLACEMENT . . . . . 31-90TIRE PRESSURE MONITORING SYSTEM (TPMS) . . . . . . . . . . . . . . . . 31-91TPMS ANTENNA . . . . . . . . . . . . . . . . . . . . 31-91REMOVAL AND INSTALLATION . . . . . . . . 31-91TPMS RECEIVER . . . . . . . . . . . . . . . . . . . . 31-93REMOVAL AND IN
7、STALLATION . . . . . . . . 31-93TPMS TRANSMITTER . . . . . . . . . . . . . . . . 31-94REMOVAL AND INSTALLATION . . . . . . . . 31-94SPECIFICATIONS . . . . . . . . . . . . . . . 31-97FASTENER TIGHTENING SPECIFICATION 31-97GENERAL SPECIFICATIONS . . . . . . . . . . 31-97SERVICE SPECIFICATIONS . . . .
8、. . . . . . . 31-98GENERAL DESCRIPTIONWHEEL AND TIRE31-2GENERAL DESCRIPTIONM1311000100327FEATURE Warns driver of low tire pressure by illuminating the TPMS warning light on the combination meter Warns driver of TPMS problems by flashing the TPMS warning light on the combination meterTIRE PRESSURE MO
9、NITORING SYSTEM (TPMS)The Tire Pressure Monitoring System (TPMS) con-sists of five TPMS transmitters (tire pressure sensors and roll switches) installed in all tires, four TPMS antennas installed inside the wheel houses, a TPMS receiver installed inside the lower quarter trim (RH), and a TPMS warnin
10、g light on the combination meter. Each TPMS antenna receives radio frequency signal output from the TPMS transmitter, the TPMS receiver interprets the signals and detects abnormal-ity of tire pressure and/or the system, and the TPMS warning light illuminates or flashes to alert. CONSTRUCTION DIAGRAM
11、AC307575AC205999HCATTEMPSRSPRND54321x1000r/min234567810AC307585TPMS ANTENNA (FRONT: RH)TPMS RECEIVERTPMS TRANSMITTER (FRONT: RH)TPMS WARNING LIGHTTPMS ANTENNA (FRONT: LH)TPMS ANTENNA (REAR: RH)TPMS ANTENNA (REAR: LH)TPMS TRANSMITTER (FRONT: LH)TPMS TRANSMITTER (REAR: RH)TPMS TRANSMITTER (REAR: LH)TP
12、MS TRANSMITTER (SPARE)ABNOTE: Each TPMS transmitter has a pressure sensor and roll switch.TSB RevisionGENERAL DESCRIPTIONWHEEL AND TIRE31-3CIRCUIT DIAGRAMAC307586RELAY BOXJUNCTION BLOCKCOMBINATION METERTPMS RECEIVERDATA LINKCONNECTORFRONT TIRE (LH) FRONT TIRE (RH) REAR TIRE (LH) REAR TIRE (RH)IGNITI
13、ON SWITCH (IG1) FUSIBLE LINKTPMSPOWERSUPPLYGNDRECEIVING CIRCUITEEPROMVEHICLESPEED SENSORCPUTPMS TRANSMITTERTPMS ANTENNA(FRONT: LH)CONTROL CIRCUITTPMS ANTENNA(FRONT: RH)CONTROL CIRCUITTPMS ANTENNA(REAR: LH)CONTROL CIRCUITCPUTRANSMISSION CIRCUITSPARE TIRE1815A610A1020A2FUSIBLE LINK 1ABANTENNATPMS ANTE
14、NNA(REAR: RH)CONTROL CIRCUITPRESSURE SENSORROLL SWITCHBATTERY The TPMS receiver processes input signals from each TPMS transmitter as well as vehicle speed signals from the vehicle speed sensor. When the road tire pressure is low, it sends a warning sig-nal causing the TPMS warning light to be illum
15、i-nated. When the TPMS has problems, it sends a warning signal causing the TPMS warning light to The TPMS transmitter includes a roll switch that senses tire rotation. The TPMS receiver can determine which tires are rotating (road tire) and stationary (spare tire). For 3 seconds after the ignition s
16、witch is turned to the ON position, the TPMS receiver illuminates the TPMS warning light to check any breaks in TSB Revisionbe flashed. the TPMS warning light circuit.GENERAL DESCRIPTIONWHEEL AND TIRE31-4 By connecting the scan tool to the data link con-nector, data stored in the TPMS receiver (data of tire pressure and tire pressure sensor ID, the alarm status and warning history, etc.) can be dis-played and the tire pressure sensor ID can be registered.TPM
