《5.管道等级汇总表》由会员分享，可在线阅读，更多相关《5.管道等级汇总表（14页珍藏版）》请在金锄头文库上搜索。
1、管 道 施 工 手 册Piping Construction ManuelTEMP RANGE(C)温度范围 (C)ATMOSPHERIC VENT大气放空 ,PLANT AIR工业风 ,CALCIUM HYDROXIDE氢氧化钙氢氧化钙 (LIME石灰 ), DECOKING AIR脱焦气 ,DILUTION STEAM稀释蒸汽 , SAFETY VENT 安全放空LBW (DEAERATED), LBW (已脱氧 )OILY-DRAIN含油液LP STEAM低压蒸汽 , LP CONDENSATE低压冷凝液FUEL GAS燃料气 , FUEL OIL燃料油 ,NITROGEN氮气 ,COO
2、LING WATER SUPPLY冷却水供给 ,RETURN回流 , INTERMEDIATE 过渡物流 (AG)(UG),CONTAMINATED WATER污水 (AG)(UG),惰性气体 ,NON-CONTAMINATED WATER非污染水 ,WASTE WATER废水 , FIREWATER 消防水 (AG),OILY WATER SEWER 含油污水 (UG) CHILLED WATER,DECANTED WATER, PROCESS WATERA1A20 150RF CS碳钢 -20 到 370 ATMOSPHERIC VENT放空 OILY WATER SEWER污油水LP S
3、TEAM低压蒸汽 FUEL GAS燃料气 LP DENSATE低压冷凝物 COOLING WATER 冷却水COOLING WATER冷却水UTILITY WATER公用工程用水EB, ORGANICS有机物 , HYDROCARBON烃 , QUENCHOIL急冷油 , STYRENE FEED苯乙烯进料 , DEVOL脱挥发份 ,RUBBER SLURRY橡胶渣泥 OLIGMERS低聚物 ,A1D20 150RF CS碳钢 -20 到 370 HYDROCARBON 碳氢化合物 QUENCH OIL急冷油A1E 150 RF CS碳钢 -10 到 316 HYDROGEN氢气A1E20 P
4、N2. 0 RF(150RF) CS碳钢 -10 到 200 HYDROGEN氢气A1F 150 RF CS碳钢 -10到 51.5 93 到 98% SULFURIC ACID93到 98%硫酸A1F20 PN2. 0 RF(150RF) CS碳钢 -20 到 200 93 到 98% SULFURIC ACID93到 98%硫酸A1J 150 RF CS碳钢 -10 到 316 BT EXTRACTION w /VACUUM抽提及 /真空A1K 150 RF CS碳钢 -10 到 260 WET / HOT FLARE干湿火炬A1K20 PN2. 0 RF(150RF) CS碳钢 -10
5、到 260 WET / HOT FLARE干湿火炬SPENT CAUSTIC废碱HYDROCARBON (WITH CAUSTIC & 5% BENZENE苯A1NR20 PN2. 0 RF(150RF) CS碳钢 -20 到 110 SPENT CAUSTIC (50% Caustic)废碱A1P 150 RF CS碳钢 -10到 427 TRANSFER LINES传送管线 HYDROCARBON 烃A1PA 150 RF CS碳钢 -10到 427 DECOKING LINES,脱焦 VACUUM SERVICES负压介质STABILIZER COLUMN OVHD (H2S ENVIR
6、ONMENT)稳定器塔塔顶 (H2S环境 )PROCESS LIQUID & VAPOUR (LETHAL W/HCN),工艺液体及蒸汽 (致命性物料及 HCN),OFFTEST ACRYLONITRILE未检验丙烯腈PARTIAL VAC CLOSED DRN部分负压倒淋关闭 ,LIQUID & VAPOUR (LETHAL -5.7PAIS)CLASS等级 RATING额定值A1A 150 RFA1D 150 RF CS碳钢CS碳钢A1AA 150 RF CS碳钢A1WR 150 RFA1X 150 RFA1NR 150 RF4、工艺管道等级汇总表PIPEMATL管道材质CS碳钢0 到 6
7、6-10到 427SERVICE 介质-10 到 371NDE CLASS探伤等级-10 到 371 ?CS碳钢 -10到 110 CS碳钢-10 到 2601管 道 施 工 手 册Piping Construction ManuelTEMP RANGE(C)温度范围 (C)CLASS等级 RATING额定值4、工艺管道等级汇总表PIPEMATL管道材质 SERVICE 介质NDE CLASS探伤等级液体及蒸汽 (致命物料 -5.7PAIS)PROCESS VAPOUR LETHAL (FULL VAC, ACRYLO &WTR)工艺蒸汽 致命性物料 (全负压 )CATALYST (FULL
8、VAC AT CATALYST HOPPERS)催化剂 (催化剂料斗全负压 )COLD FLARE冷火炬 , ETHYLENE REFRIG.制冷乙烯 ,L.T. HYDROCARBON低温烃 ,LIQUID DRAIN液体倒淋 ,PPL REFRIGERANT制冷剂CHLORINATED WATER含氯水CHLORINE DIOXIDE二氧化氯DILUTE H2SO4 PARTIAL FLOW W / AIR,稀释液 H2SO4 部分液流及 / 空气FERRIC CHLORIDE氯化铁 , SODIUM CHLORIDE氯化钠SODIUM CHLORIDE氯化钠 ,SODIUM BISULF
9、ITE二硫化钠 , SODIUM HYPOCHLORITEACID DRAINS (98% H2S04) SULFURIC ACID (A/GRDonly)次氯酸钠倒淋 (98% H2S04) 硫酸 (仅 A/GRD)HYDROCHLORIC ACID (31%)盐酸A6A20 PN2. 0 RF(150RF) LINED CS(PVDF) -20 到 93 BCHLORINATED WATER 氯水 CHLORINE DIOXIDE 氯酸DILUTE H2SO4 PARTIAL FLOW W / AIR稀硫酸FERRIC CHLORIDE SODIUM CHLORIDE SODIUMBISU
10、LFITE SODIUM HYPOCHLORITE ACID DRAINS(98% H2S04) SULFURIC ACID (A/GRD only) 浓硫酸DEMINERALIZED WATER (NON-DEAERATED BFW)PHOSPHATE磷酸盐, NSIA21A19 PN2. 0 RF150 0Cr19Ni9S/Stl -29 到 204 DEMINERALIZED WATER 软水BIOCIDE SOLUTION除菌溶液 DISPERSANT扩散剂 ,CORROSION INHIBI到 R防腐剂 PHOSPHATE磷酸盐 , NSIBIOCIDE SOLUTION除菌溶液CO
11、RROSION INHIBI到 R防腐剂DISPERSANT扩散剂 ,PHOSPHATEA21C 150 RFLJ 304 SS -29 到 204 HYDRAZINE肼LUBE AND SEAL OIL润滑及密封油(HIGH AND LOW PRESSURE)高压和低压A21K19PN2. 0RFWN(150RF)0Cr19Ni9S/Stl -101 到 204 DRY FLARE干火炬 , LIQUID DRAIN液体倒淋 ,L.T. HYDROCARBON低温烃A21L19PN2. 0RFWN(150RF)0Cr19Ni9S/Stl -196 到 204 DRY FLARE干火炬 , L
12、IQUID DRAIN液体倒淋 , L.T.HYDROCARBON低温烃A1X 150 RFA2A 150 RFA6A 150 RFA1Y 150 RFA21A 150 RFLJ 304 SSA21B 150 RFWN 304 SSA21D 150 RFLJ 304 SSA21K 150 RFWNA21B19 PN2. 0RFLJ (150#) 0Cr19Ni9S/StlDRY FLARE干火炬 , LIQUID DRAIN液体倒淋 ,L.T. HYDROCARBON低温烃A21L 150 RFWN DRY FLARE干火炬 , LIQUID DRAIN液体倒淋 , L.T.HYDROCARB
13、ON低温烃-196到 204 -101到 204 304 SS304 SS-10 到 371 ?CS碳钢LINED CS衬碳钢-29 到 204 -10 到 371 ?LTCS -46到 260 CS碳钢-29 到 204 -29 到 204 -17 到 93 B-29 到 2042管 道 施 工 手 册Piping Construction ManuelTEMP RANGE(C)温度范围 (C)CLASS等级 RATING额定值4、工艺管道等级汇总表PIPEMATL管道材质 SERVICE 介质NDE CLASS探伤等级A22A 150 RF 304(L) SS -29 到 160 ? GA
14、SEOUS OXYGEN PROCESS LIQUID/VAPOURCLOSED DRAIN气态氧工艺流体蒸汽倒淋关闭A22D 150 RFLJ 304(L) SS -13 到 150 ? POWDER & PELLET CONVEYING粉粒料传输POWDER & PELLET粉及粒料 (GRAVITY重力传输 ),POLYETHYLENE PELLET聚乙烯粒料PELLET ADDITIVE粒料添加剂CATALYST CONVEYING VENT催化剂输送放空 , POLYSTYRENE VENT聚苯乙烯放空POWDER & PELLET (GRAVITY)粉粒料 (重力传输 )CONVE
15、YING AIR传输空气POWDER / PELLET (GRAVITY LINES) 粉粒料PELLET ADDITIVE粒料添加剂POWDER粉料 , POLYETHYLENE PELLET聚乙烯粒料SOFTENED WATER软化水 STYRENE苯乙烯COLD DEMIN WATER冷却脱盐水A23L17 RF150 00Cr17Ni14Mo2 S/Stl 0 到 300 ? SOFTENED WATER COLD DEMIN WATER STYRENESULPHUR DIOXIDE 二氧化硫 (DRY干态 )PHOSPHATE磷酸盐 , AMINE胺 , MAC + H2O M酸 + H2OCRUDE & WEAK MAC原 M酸及弱 M酸ACRYLIC/ACETIC ACID丙烯酸 /醋酸AMINE胺 , PHOSPHATE磷酸盐 MAC + H2O M酸 + H2OCRUDE & WEAK MAC原 M酸及弱 M酸ACRYLIC/ACETIC ACID丙烯酸 /醋酸GLYCOL ACID 乙二醇酸PROCESS FLARE (LETHAL HCN)工艺火炬 (致命性 HCN)PROCESS LIQUID / VAPOUR (LETHAL
