《plc控制电梯论文》由会员分享，可在线阅读，更多相关《plc控制电梯论文（60页珍藏版）》请在金锄头文库上搜索。
1、plc 控制电梯论文Iplc 控制电梯论文摘 要随着科学技术和社会经济的发展，高层建筑已成为现代城市的标志。电梯作为垂直运输工具，承担着大量的人流和物流的输送，其作用在建筑物中至关重要。与此同时，人们对电梯的性能要求也越来越高，比如可靠性，操作方便，舒适性，低噪音，低能耗等等。随着人们对其要求的提高，电梯得到了快速发展，其拖动技术已经发展到了调频调压调速，其逻辑控制也由 PLC 代替原来的继电器控制。采用 PLC 对电梯进行控制，通过合理的选择和设计，能够有效的提高电梯的控制水平，极大地改善了电梯运行的舒适感，使电梯的控制达到了比较理想的控制效果。本文在介绍电梯基本结构的基础上，阐述了电梯的拖
2、动原理和控制原理，重点分析了电梯系统设计中如何用 PLC 实现控制系统并编制控制程序，研究并提出了基于 PLC 和变频器的电梯控制系统的实现方案，针对这些问题对电梯系统进行了新的设计.设计出了新的采用 PLC 进行逻辑控制，用变频器调速的电梯控制系统。利用三菱 PLCFX2N-64 来设计 5 层电梯控制系统。关键词：电梯；控制系统；PLC；变频器plc 控制电梯论文IIABSTRACTWith scientific and technological and socio-economic development, high-rise buildings have become the hal
3、lmark of modern cities. As vertical lift equipment, a lot of people bear the transportation and logistics, its role in building essential. At the same time, it has to lift the performance requirements are also increasing, such as reliability, easy to operate, comfortable nature, low noise, consumpti
4、on, and so on. But the elevator as an important traffic in skyscraper，it also has developed quickly with the improving requirement of the People. Its dragging technology has developed from DC timing to AC variable frequency timing and Its logic control-relay control also has been replaced by PLC. us
5、ing PLC to control the elevator，the reliability is improved and the feeling of comfort 15 better through the reasonable selection and design，so the effect of control is more ideal. In order to meet the comfort, improve transporting efficiency and reach the right floor, the given curve of an elevator
6、 is a key point. Most of peoples sensitivity on changing speed is about acceleration movement. Comfort means acceleration and deceleration on smoothness. To acquire favorable comfort, the starting and braking curves design of the elevator is composed of two s-curves and one beeline. Through adjustin
7、g the acceleration time and that of the s-curves, ideal starting and braking curves are gained.This paper, based on the introduction of the elevators basic structure, expatiates the drive and control principle of elevator, and analyzes how to use the PLC to program controlling process. The implement
8、ation project of elevators VVVF control system based on PLC and transducer is studied and proposed. This article was precisely has carried on the improvement design in view of these questions to the existing elevator system. Uses PLC to carry on the logical control modulates velocity the elevator co
9、ntrol system with the frequency changer.KEY WORDS: elevator；control system；PLC；inverterplc 控制电梯论文III目 录摘 要 .IABSTRACT .II1 前言 .11.1 电梯的起源和发展 .11.2 电梯信号控制系统发展的现状 .21.2.1 电梯继电器控制系统的特点及存在问题 .31.2.2 PLC 及在电梯控制中的应用特点 .41.2.3 PLC 控制电梯的优点 .51.3 本文的工作 .52 电梯的概述 .62.1 电梯的结构 .62.2 电梯的控制要求 .83 硬件选择 .103.1 PLC 的选择 .103.1.1 PLC 的定义和特点 .103.1.2 PLC 的主要功能和应用 .133.1.3 PLC 与其他工业控制系统的比较 .143.1.4 PLC 的系统硬件设计 .163.1.5 可编程控制器机型的选择 .173.2 变频器选择 .193.2.1 变频器的分类 .193.2.2 变频器的控制方式 .19plc 控制电梯论文IV3.2.3 变频器的选型 .213.2.4 变频器的相关计算及其规格 .224 五层电梯总体设计 .254.1 电机调速系统的设计 .254.2 电力调速系统的应用与发展 .264.3
