《控制系统IC应用幻灯片资料》由会员分享，可在线阅读，更多相关《控制系统IC应用幻灯片资料（34页珍藏版）》请在金锄头文库上搜索。
1、核心元器件产品,盛涛 工控元器件产品业务经理，北区,Copyright 2007 Rockwell Automation, Inc. All rights reserved.,Infrastructure for the Architecture,Integrated Architecture,Transformers Power Supplies UPS,MCBs Surge Filters,GP Relays Signal Conditioners,Terminal Blocks Wiring Systems,Show Video,Copyright 2007 Rockwell Autom
2、ation, Inc. All rights reserved.,Infrastructure for the Architecture- Power Supply Applications,Din Rail Power Supplies,DC and Analog I/O,When you see this,Ask about,Page 2-87 in the EC catalog for product family overview,Copyright 2007 Rockwell Automation, Inc. All rights reserved.,Redundancy,1+1 R
3、edundant system Full Size Power Supply to support load, i.e., 2A Load distributed between the power supplies On failure, the other power supply would take over,N+1 Redundant system Greater than 2 power supplies to carry load, i.e., 2 -10A power supplies for 20A load, +1 module 10A Load distributed b
4、etween the supplies On failure, the other power supplies would take over the load,Copyright 2007 Rockwell Automation, Inc. All rights reserved.,6,Where is a DC Power Supply placed in the control circuit and how much does it cost?,Supply- $xxx Control Circuit Transformer Power Supply- DC In Power Boo
5、st 144W,Peak characteristic of one motor,Peak Power Demand = 7.0A or 168W Continuous Current Demand = 2.9A or 69.6W,Copyright 2007 Rockwell Automation, Inc. All rights reserved.,Success Story Increased Hold-Up Time,Background Customer was looking for a way to bridge main faults without interruptionc
6、ost effective method to increase reliability of their system. Solution Utilize a 1606-XLBuffer in conjunction with a 24V DC power supply Works like a DC-UPS with short hold-up time, . but utilizes electrolytic capacitors as energy storage Maintenance-Free, no battery replacement Main faults are comp
7、letely bridged by the buffer unit and will have no influence on the DC power 200 msec for 20A, 3.6 secs for 1A Wire units in parallel for longer hold-up times,Copyright 2007 Rockwell Automation, Inc. All rights reserved.,Success Story Low Noise/Ripple,Background Conversion opportunity.customer tradi
8、tionally used linear power supplies. Has been reluctant to make the change to switch mode power supplies due to the increased noise levels. Solution Allen-Bradleys 1606 Power Supplies provide superior EMC performance Resistant to Noise Low Emissions Ripple/Noise levels across the entire 1606 Family
9、are on average 50mVpp Most competitive products have between 10-20 x the noise levels of the 1606 products.,Copyright 2007 Rockwell Automation, Inc. All rights reserved.,Success Story DeviceNet,Background Customer had a requirement for an 8A power supply that was ODVA certified Solution Allen-Bradle
10、ys new 1606-XLS Performance Line offers 2 products with the ODVA certification: 1606-XLSDNET4 1606-XLSLDNET8 Most competitors have not gone the “extra step” to have their units conformance tested by ODVA and therefore cannot have the official marking on their power supply.,Copyright 2007 Rockwell Au
11、tomation, Inc. All rights reserved.,Infrastructure for the Architecture- UPS Applications,Uninterruptible Power Supplies,VersaView,When you see this,Ask about,Ethernet Switches,or,Page 2-91 in the EC catalog for product family overview,or,Copyright 2007 Rockwell Automation, Inc. All rights reserved.
12、,UPS Selection,How do I select a Rockwell 1609 Industrial UPS? Use the Selection Guide / User manual to determine the load requirement (Voltage and Current draw) of the Industrial Computer Input voltage = 120Vac Input Current = 1.25A Power = 120 x1.25 = 150Va load,1609-UPS Selection: (EC: 2-92) Sele
13、ct a UPS with a higher Va rating than the PC 1609-S350NS (120Vac, 350Va, No Communication) 1609-U500NS (120Vac, 500Va, with communication capabilities) UPS run time, use the load / runtime chart for the selection The chart shows at 150VA and 120VAC: approx 24 minutes of run time,Copyright 2007 Rockw
14、ell Automation, Inc. All rights reserved.,16,Schematic- Where are the UPSs placed in the control circuit and how much do they cost?,Supply- $xxx Control Circuit Transformer Power Supply- DC In & Out Power Supply- Analog In & Out Power Supply- E-Net Switch AC UPS- VersaView DC UPS- Ethernet Switch,Af
15、ter quantifying the value of theUPSs, it will add $xxxx to the bill of material,480 VAC,10 Hp Blower,“Infrastructure for the Architecture”,120 VAC,Inputs,24 VDC,Ethernet,J Type Thermocouple,4-20mA Isolated,Derrick, Please verify UPS pricing at lg oem for both the Ac & DC UPS and battery.,Copyright 2
16、007 Rockwell Automation, Inc. All rights reserved.,1609 UPS,1 of 4,UPS产品线：RA目前的UPS产品主要有3个系列 1609-S 350VA 1609-U 500VA, 1609-U 750VA,1000VA,2000VA 1609-P 3000-10KVA 其中，U和S系列是我们比较有特点的产品 主要特点：U和S系列真正的工业级UPS 可采用DIN安装方式 运行效率96以上，散热很少，可安装于盘柜内部 提供干节点输出，可将UPS状态信号传送至PLC等外部监控设备 提供工业级高温电池（50）,Copyright 2007 Rockwell Automation, Inc. All rights reserved.,集成架构中的“保护装置”,微型断路器,I/O Wiring,When you see this,Ask about,Copyright 2007 Rockwe
