《不锈钢水箱使用说明》由会员分享，可在线阅读，更多相关《不锈钢水箱使用说明（2页珍藏版）》请在金锄头文库上搜索。
1、上海辉旗环保科技有限公司 不锈钢水箱安装使用说明Stainless steel water tank installation instructions一、 本系列水箱为上海辉旗不锈钢SUS304材质制品；具有极高的耐腐蚀性，不锈钢水箱体采用凸面模板拼装焊接，可根据现场的结构，不同的尺寸要求，不同的吨位要求进行灵活组装，耗材较少，结构强度较高，无需大型吊装设备，运输方便；This series of shanghai huiqi water tank is a stainless steel SUS304 material products; with high corrosion resis
2、tance, stainless steel water tank body adopts convex template assembling and welding, according to the structure, different size, different tonnage requirements for flexible assembly, less consumables, the structural strength is high, there is no need of large lifting equipment, transportation conve
3、nient;二、 水箱在使用前核对设计图纸，尺寸、箱体开孔位置与设计图相符；Water before use to check the design drawings, size, the hole position and design;三、 安装前将基础梁垫水平，水箱底部平面必须固定在同一水平面上，不可擅自移动水箱位置或方向；槽钢支架应用螺丝或水泥固定，放置位置靠近墙体，需另设防护网，以防支架锈蚀或大风导致意外；The foundation beam pad level before installation, the plane at the bottom of the tank mus
4、t be fixed at the same level, can not be arbitrarily mobile tank position or direction; the fixed supporter with screws or cement, placed near the wall, the need of additional protective net, to prevent corrosion or wind guide greets outside support;四、 不锈钢方形水箱基础要求：砼基础几何尺寸应按GB02S101有关规定制定；砼基础平面高低差5mm
5、；砼基础的尺寸应根据水箱的大小保持一致，相邻两条基础的中心距离800mm，单条砼基础的宽度200mm；Stainless steel square water tank foundation requirements: concrete foundation geometry size should be in accordance with the relevant provisions of the GB02S101 formulation; concrete foundation level difference of 5mm; the concrete foundation shoul
6、d be sized according to the size of the tank to maintain consistent, two adjacent foundation center distance 800mm, the concrete foundation of single width, 200mm;五、 水箱配管时，不可向进水口施加过大的负荷；不要将阀门及大口径管道的重量直接施加到水箱水口，必要时应设置管道支撑；对焊接管的膨胀、收缩、振动必须装伸缩柔性接头；The water tank water inlet piping, not to impose an exce
7、ssive load; dont be valves and large diameter pipeline weight applied directly to the water outlet, when necessary, set the pipe support; the welding pipe expansion, contraction, vibration must be loaded telescopic flexible joint;六、 水箱在安装过程中，不得在水箱顶部放置其他笨重物品或设备，不要用硬物随意敲打或图画水箱表面及管件，水箱的溢水口有进、排气作用，不可堵塞，
8、溢流孔严禁设置阀门，不得与排水管道直接连接；The water tank in the installation process, or other heavy objects or device is placed at the top of the tank, dont beat or a picture of the surface of the water tank and pipe fittings with a hard object, overflow tank, exhaust into action, can not plug valve, overflow hole was
9、 strictly prohibited, not connected with the drainage pipe directly;七、 作为储存生活用水的二次设备，只能装生活用水(消防用水)，水箱入孔盖不要随意打开，防止水质受二次污染，不能装盐酸、硫酸或酸性、碱性含量较大的液体；As the two equipment storage life in the water, can only be installed water (water), water tank hoods do not arbitrarily open, prevent water from pollution t
10、wo, hydrochloric acid, sulfuric acid or acid can not be installed, the alkali content of the liquid;八、 在使用之前一定要注清水，打开排污阀放掉，然后再注清水方可使用；严禁倒置、重压、推滚与棒击，以免损坏产品的密封造成渗漏；In the use of prior to injection water, the drain valve is opened out, and then note the water can be used; no inversion, weight, rolled a
11、nd bludgeon, so as not to damage the seal leakage caused by product;九、严禁与明火接近，应避离电焊和气割，水箱如在屋顶，使用方必须安装防雷设施；No close to the flame, should avoid welding and cutting, such as in the roof water tank, used to install lightning protection facilities;十、 安装单位请参照此说明安装，否则本公司不予质保。咨询：+86 021-69106065Please refer to the installation unit installation, otherwise, the company will not warranty. Advisory: +86 021-69106065 上海辉旗环保科技有限公司 Shanghai Hui Qi Environmental Protection Technology Co., Ltd.
