《过滤器-反渗透-混床步序表》由会员分享，可在线阅读，更多相关《过滤器-反渗透-混床步序表（8页珍藏版）》请在金锄头文库上搜索。
1、-PT. PLN BATAMTanjung Kasam Coal Fired Steam Power Plant2*65MWPower Plant Project印尼BATAM TJK 265MW燃煤电厂工程DESALINATION WATER TREATMENT SYSTEM海水淡化及锅炉补给水处理系统步序表OPERATION PROCEDURE TABLE中国华电工程集团CHINA HUADIAN ENGINEERING CO., LTD.1. 多介质过滤器Multi-media Filter序号阀门/设备名称VALVE/EQUIPMENT NAMEKKS编码KKS Code运行Put i
2、nto run停用反洗Backflushing充水Filling正洗Rinsing运行Service停用OFF排水1Drain空气擦洗SCOURING水反洗Water BACKFLUSHING1.进水阀INLETAOGCB51AA102开开开关关关关2.出水阀OUTLETAOGCB51AA106关关开关关关关3.反洗进水阀BACKFLUSHING INLET AOGCB51AA103关关关关关关开4.反洗排水阀BACKFLUSHING DRAIN AOGCB51AA105关关关关关关开5.正洗排水阀RINSING DRAINAOGCB51AA107关开关关开关关6.擦洗空气进口阀SCOURIN
3、G AIR INLETAOGCB51AA104关关关关关开关7.排气阀VENTAOGCB51AA101开关关关开开关8.流量FLOW70m3/h70m3/h70m3/h4Nm3/min4Nm3/min9.持续时间TIME2min15min现场设定510min510min备注：1. 排水至滤料层上200mm，该步序完毕。2. 过滤器投入运行，同时参加凝聚剂，凝聚剂投加量根据进出水浊度和流量调节。2. 海水反渗透单元SWRO Unit序号阀门/设备名称VALVE/EQUIPMENT NAMEKKS编码KKS Code运行Put into run停用OFF翻开产水排放阀Open Permeate D
4、ischarge Valve冲洗Sluicing产水排放1Permeate Discharge运行Service翻开产水排放阀Open Permeate Discharge Valve停泵PumpStop低压冲洗Sluicing停顿OFF1.反渗透进水阀RO Inlet AOGCF41AA101关开开开开关关关2.产水排放阀Permeate DischargeAOGCF41AA102开开开关开开开关3.低压冲洗进水阀Sluice InletAOGCF41AA103关关关关关关关关4.一级高压泵SWRO High Pressure PumpAOGCF41AP001关关开开开关关关5.增压泵Boo
5、ster PumpAOGCF41AP002关关开开开关关关6.海水反渗透冲洗水泵SWRO Flushing PumpsAOGCP31AP001关关关关关关开关7.酸计量泵Acid Dosing PumpAOGCN81AP001关关开开开关关关8.复原剂计量泵SBS Dosing PumpA0QCB21AP001/A0QCB22AP001关开开开开关关关9.阻垢剂计量泵Scale Inhibitor Dosing PumpA0QCF21AP001/A0QCF22AP001关关开开开关关关10.流量FLOW高压泵流量：25m3/h增压泵流量：46m3/h高压泵流量：25m3/h增压泵流量：46m3
6、/h10min11.持续时间TIME15min5min10min备注：1. 初滤水排放至产品水电导到设定值，该步序完毕。2. SWRO 起动前先过滤器1套反渗透，至少起动2台过滤器；海水反渗透停顿运行后，过滤器才能退出运行。3. 复原剂计量泵和ORP连锁；酸计量泵和pH连锁4. 高压泵和进口压力开关连锁。5. 高压泵和增压泵连锁，保持流量和压力稳定。3. 二级反渗透单元BWRO Unit序号阀门/设备名称VALVE/EQUIPMENT NAMEKKS编码KKS Code运行Put into run停用OFF翻开产水排放阀Open Permeate Discharge Valve冲洗Sluici
7、ng产水排放1Permeate Discharge运行Service翻开产水排放阀Open Permeate Discharge Valve停高压泵High PressurePumpStop低压冲洗Sluicing停顿OFF1.产水排放阀Permeate DischargeAOGCF43AA102开开开关开开开关2.低压冲洗进水阀Sluice InletAOGCF43AA103关关关关关关关关3.二级高压泵BWRO High Pressure PumpAOGCF43AP001关关开开开关关关4.反渗透冲洗水泵BWRO Flushing PumpsAOGCP32AP001关关关关关关开关5.碱计
8、量泵Caustic Dosing PumpAOGCN85AP001关关开开开关关关6.流量FLOW15min5min10min7.持续时间TIME备注：1. 初滤水排放至产品水电导到设定值，该步序完毕。2. 碱计量泵和pH连锁。3. 高压泵和进口压力开关连锁。4. 混床Mi*ed Bed Polisher设备名称阀门名称VALVE NAMEKKS码 KKS CODE运行步骤运行service停用off反洗分层Backflushing for separation沉降Settle再生Regeneration置换displacement排水drain混脂Resin mi*ing设备充水fillin
9、g正洗rinsing停用off混床Mi*ed bed polisher 进水阀INLET VALVEA0GCF21AA102开所有表中所列阀门、泵处于关闭状态关关关关关关开开所有表中所列阀门、泵处于关闭状态出水阀OUTLET VALVEA0GCF21AA110开关关关关关关关关反洗进水阀BACKFULISHING INLETA0GCF21AA104关开关关关关关关关反洗排水阀BACKFLUSHING DRAINA0GCF21AA107关开关关关关开关关中排阀MIDDLE DRAIN VALVEA0GCF21AA108关关关开开关关关关进酸阀ACID INLETA0GCF21AA105关关关开开
10、关关关关进碱阀CAUSTIC INLETA0GCF21AA103关关关开开关关关关排积水阀Top DrainA0GCF21AA109关关关关关开关关关进压缩空气AIR INLETA0GCF21AA106关关关关关关开关关正洗排水阀RINSINGA0GCF21AA111关关关关关关关关开排气阀VENTA0GCF21AA101关关开关关开关开关混床用酸喷射器进稀释水阀Acid Dilution water inletA0GCN83AA101关关关开开关关关关进酸阀Acid inletA0GCN83AA102关关关开关关关关关混床用碱喷射器进稀释水阀Caustic dilution water inletA0GCN87AA101关关关开开关关关关进碱阀Caustic inletA0GCN87AA102关关关开关关关关关时间Time15min8min30min60min8min10min3min15min流量m3/h运行周期根据出水电导和硅含量确定时间可人工设定时间可人工设定再生泵开启0.5min后再进展此步骤时间可人工设定时间可人工设定时间可人工设定时间可人工设定时间可人工设定持续时间备注：. z.
