《钢丝绳新标准》由会员分享，可在线阅读，更多相关《钢丝绳新标准（22页珍藏版）》请在金锄头文库上搜索。
1、钢丝绳新标准一、 新旧标准主要标记代号对照名称GB8707-88GB1102-74、YB829-79西鲁式钢丝绳SX瓦林吞式钢丝绳WW填充式钢丝绳FiT面接触钢丝绳TM圆股无代号无代号三角股V椭圆股QO纤维芯（天然或合成）FC纤维芯天然纤维芯NF纤维芯合成纤维芯SF纤维芯钢丝绳芯IWR金属绳芯钢丝股芯IWS光面钢丝NAT光A类镀锌钢丝ZAAAB类镀锌钢丝ZABB类镀锌钢丝ZBB甲组镀锌钢丝甲镀乙组镀锌钢丝乙镀右交互捻ZS右交左交互捻SZ左交右同向捻ZZ右同左同向捻SS左同二、 钢丝绳的标记1 全称标记示例及说明例1 （摘自GB1102-74）例2 （摘自GB8707-88，将原标准号GB110
2、2改为GB/T8918-1996）例3 （摘自GB8707-88，将原标准号GB1102改为GB/T8918）18ZAA6(9+9+1)+SF1770ZSGB/T89182 简化标记示例（摘自GB8707-88） 18NAT619SNF1770ZZ190 18ZBB619WNF1770ZZ 18NAT625Fi+IWR1770 18ZAA619SNF通常使用最多的是简化标记，而且是上述示例中最后（最简单）的一个。GB/T8918和GB/T16269，钢丝绳的公称直径全为整数，14mm以上全为偶数。钢丝绳选择：推荐表供选绳参考，表里每栏中钢丝绳的排列顺序，基本按绳径由小到大。用途矿井条件名称结构
3、备注立井淋水大，酸碱度高，锈蚀严重或涂油困难的矿井异型股钢丝绳6V21，6V30，6V33，6V36，6V37S，6V43，6Q196V21，6Q336V21选用镀锌钢丝绳圆股钢丝绳619S，621W，625Fi，629Fi，626SW，631SW，636SW，641SW锈蚀与磨损都较轻的矿井异型股钢丝绳6V21，6V30，6V33，6V36，6V37S，6V43，6Q196V21，6Q336V21圆股钢丝绳619W，625Fi，629Fi，636SW摩擦轮式提升矿井异型股钢丝绳6V21，6V30，6V37S，6Q196V21选用镀锌钢丝绳开凿立井用绳异型股钢丝绳6Q196V21，6Q336V
4、21如挤压变形严重，应选用钢芯钢丝绳多层股钢丝绳177，187，347，367，面接触钢丝绳6T19W，6T19S，6T25Fi平衡尾绳多层股钢丝绳177，187，347，367，选用交互捻罐道用绳密封钢丝绳，6V18，67，67+IWS见密封钢丝绳标准，其余结构应选用镀锌钢丝绳斜井锈蚀与摩擦都较严重的矿井异型股钢丝绳6V18选用镀锌钢丝绳圆股股钢丝绳67，619S，69面接触钢丝绳6T7，6T19S，锈蚀较轻磨损严重的矿井异型股钢丝绳6V18圆股股钢丝绳67，619S，69W面接触钢丝绳6T7，6T19Si锈蚀与磨损都较轻，断丝发展较快的矿井异型股钢丝绳6V18，6V21圆股股钢丝绳619S
5、，625Fi面接触钢丝绳6T19S，6T25Fi钢丝绳力学性能表21 第一组 67类钢丝绳结构：67FC，67IWS，69WFC，69WIWR，钢丝绳公称直径钢丝绳近视重量钢丝绳公称抗拉强度，MPa14701570167017701870钢丝绳最小破断拉力d允许偏差天然纤维芯钢丝绳合成纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳mmKg/100mKN2801.41.381.551.952.112.082.252.212.392.352.542.482.6833.163.103.484.394.744.695
6、.074.985.395.285.715.586.044705.625.506.197.808.448.339.018.879.599.4010.109.9310.7058.778.609.6812.2013.1013.0014.0013.8014.9014.6015.80155016.7066012.6012.4013.9017.5018.9018.7020.2019.9021.5021.1022.8022.3024.10717.2016.9019.0023.9025.8025.5027.6027.1029.3028.7031.1030.4032.80822.5022.0024.8031.2
7、033.7033.0036.0035.4038.3037.6040.6039.7042.90928.4027.9031.3039.5042.7042.2045.6044.9048.5047.5051.4050.2054.301035.1034.4038.7048.8052.7052.1056.3055.4059.9058.7063.5062.0067.101142.5041.6046.8059.0063.8063.0068.1067.0072.5071.1076.8075.1081.201250.5049.5055.7070.2075.9075.0081.1079.8086.3084.6091
8、.5089.4096.601359.3058.1065.4082.4089.1088.0095.2093.70101.0099.30107.00104.00113.001468.8067.4075.9095.60103.00102.00110.00108.00117.00115.00124.00121.00131.001689.9088.1099.10124.00135.00133.00144.00141.00153.00150.00162.00158.00171.0018114.00111.00125.00158.00170.00168.00182.00179.00194.00190.002
9、05.00201.00217.0020140.00138.00155.00195.00211.00208.00225.00221.00239.00235.00254.00248.00268.0022170.00166.00187.00236.00255.00252.00272.00268.00290.00284.00307.00300.00324.0024202.00198.00223.00281.00303.00300.00324.00319.00345.00338.00366.00357.00386.0026237.00233.00262.00329.00356.00352.00381.0
10、0374.00405.00397.00429.00419.00453.0028275.00270.00303.00382.00413.00408.00441.00434.00470.00460.00498.00486.00526.00（30）316.00310.00348.00439.00474.00469.00507.00498.00539.00528.00571.00558.00604.003260359.00352.00396.00499.00540.00533.00577.00567.00613.00601.00650.00635.00687.00（34）406.00398.00447
11、.00564.00610.00602.00651.00640.00693.00679.00734.00717.00776.0036455.00446.00502.00632.00683.00675.00730.00718.00776.00761.00823.00804.00870.00最小钢丝破断拉力总和钢丝绳最小破断拉力1.134（纤维芯）或1.214（钢芯）。钢丝绳力学性能表22 第二组 619（a）类钢丝绳结构：619S+FC，619S+IWR，619W+FC，619WIWR，619W+IWR 钢丝绳公称直径钢丝绳近视重量钢丝绳公称抗拉强度，MPa14701570167017701870钢丝绳最小破断拉力d允许偏差天然纤维芯钢丝绳合成纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳纤维芯钢丝绳钢芯钢丝绳mmKg/100mKN66013.3013.0014.6017.4018.8018.6020.1019.8021.4021.0022.6022.2023.90718.1017.6019.9023.7025.6025.3027.3027.0029.1028.6030.8030.2032.60
