《醇酸红丹防锈漆功能简介》由会员分享，可在线阅读，更多相关《醇酸红丹防锈漆功能简介（2页珍藏版）》请在金锄头文库上搜索。
1、Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 25Kg in 20 liter container 25 公斤装于 20 公升容器中Flash Point 闪点 38StorageStorage andand HandlingHandling 贮存与管理贮存与管理Specific Gravity 比重 Approx 1.4Kg/L 1.4 公斤/公升来源 http:/www.nsk- 纽克莱官网Intended Uses 用途用途用于轻微和中等腐蚀的海洋及工业环境中的黑色金属表面打底防锈，不可用于水下部位
2、。 Used for ferrous mental surface in mildly or moderately corrosive marine and industry environment as anticorroisve primer, but unsuitable for underwater area.Product Information 产品简介产品简介桔红色，漆膜坚硬，防锈性好，干燥快。 It forms a tough film with good corrosion resistance, quick dryVolume Solids 固体份39.5%Dry Flm
3、Thickness干膜厚度50microns 50 微米Theoretical Coverage 理论涂布率5.7m2 /Kg 5.7 平方米/公斤Application details 产品数据产品数据Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗Mix Radio 混合比One package 单罐装Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or Roller 涂刷或辊涂 Recommended 推荐采用Conventional Spra
4、y 传统喷涂 Not Recommended 不推荐使用Thinner 稀释剂 二甲苯Cleaner 油漆设备清洗剂 二甲苯Pot Life 使用期 Not limit 不限制Storage 贮存期 One year 一年Over coating Interval覆涂间隔SubstrateTemperature底材温度Touch Dry表干（h）Hard Dry硬干(h）Min 最短Max 最长Storage and Handling 施工详述施工详述Drying time 干燥时间5233510422418824 hours 小时16 hours 小时10 hours 小时3months 3
5、 个月 醇醇酸酸红红丹丹防防锈锈漆漆功功能能简简介介 Specification and Surface preparation 技技术术要要求求及及表表面面处处New steel The surface must be rust-removed to Swedish St3 or Sa2.5 Other conditions, please refer to related section of alkyd primer 新钢结构: 需经除锈达到瑞典标准 St3 级或 Sa2.5 其他情况请参阅醇酸底漆有关部分 Safety Precautions 安安全全措措施施 This product
6、 should be used in painting area by perfessional operators. When painting , please refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying this product. This product is a kind of solvent-based paint .I
7、norder to avoid danger or accident, minimal safety precautions,as follow , should be down . The paint contains volatile solvent and is flammable . So must keep away from sparks and open flames.No smoking at applacation site ,Effective precautions (such as using explosion-proof electrical equipments.
8、 No static electricity accumulation or metal collision etc) also should be done so as to avoid producting sparks .Flash point of paint , mentioned above on product Data sheet, is the lowest temperature at which mixture of the volatile materails of paint can ignite or explode with air. Enough ventila
9、tion is necessary at application site. In order to remove any danger of explosion, must keep the ratio of gas to air is less than 10%, the minimum explosive limit in general, Therefore, 200m3 of ventilation quantuty per 1Kg solvent (according to the solvent ) is necessary. Product skin and eyes, and
10、 avoid touching with paints (Recommend to wear working clothes, gloves,eye protection, face masks barrier cream and so on ). Kif paint gets in touch with skin , wass fully with large amount of fresh water and soap or appropriate commercial cleaner. In case of eyes being contaminated, rinse with fres
11、h water for 10min at least and give medical treatment immediately. Recommend face guard with ventilation pipe for the sake of no absorption of paint fog and harmful solvent gas, especially in bad ventilation. Handle empty containers with care and do not bring about environmental contamination. NOTIC
12、E: If consumers have not taken effective safety precautions(Refer to the specfications), our company will NOTbe responsible for any accident. 本产品由专业人缘在工业场所使用,使用时请参照本说明书及健康安全手册,如客户在使用本产品前,未能仔细了解有关产品的健康安全知识,请与本公司联系. 该涂料为溶剂型涂料,为避免事故或危险发生,应采取最低限度的安全措施如下: 此涂料为易燃物,并含有挥发性易燃溶剂,故必须远离火星和明火,严禁在作业场所吸烟,并采取有效措施,防
13、止火星产生(如采用防爆电器设备,杜绝静电积累,避免金属撞击等)本产品说明书中所列涂料及溶剂的闪点是引起燃烧的最低温度. 施工场所应尽量进行通风良好,为消除使用过程中的爆炸隐患,应保证足够的通风量以维持气体/空气比例不超过最低爆炸极限的 10%,通常每千克溶剂需要 200 立方米通风量,(与溶剂种类相关)就能维持最低爆炸极限 10%的工作环境. 采取有效措施以防止皮肤和眼睛与涂料接触(如使用工作服,手套,护目镜,面罩及涂防护油等)如产品不慎接触到皮肤,应用温水及肥皂或适当的工业清洁剂彻底清洗,如眼睛受到污染,用清水冲洗至少 10 分钟,并立即就医. 建议佩戴通风面罩以避免吸入漆雾和有害溶剂气体,尤其在通风不良环境下施工时,细心处理旧漆桶以免污染环境. 责任声明: 对于未按本公司要求采取有效安全措施儿引起的安全事故,本公司不负任何责任.
