《转向器英文文献翻译》由会员分享，可在线阅读，更多相关《转向器英文文献翻译（17页珍藏版）》请在金锄头文库上搜索。
1、1 英文文献翻译 1.1 Electronic power steering systemWhat it is：Electrically powered steering uses an electric motor to drive either the power steering hydraulic pump or the steering linkage directly. The power steering function is therefore independent of engine speed, resulting in significant energy savin
2、gs.How it works :Conventional power steering systems use an engine accessory belt to drive the pump, providing pressurized fluid that operates a piston in the power steering gear or actuator to assist the driver.In electro-hydraulic steering, one electrically powered steering concept uses a high eff
3、iciency pump driven by an electric motor. Pump speed is regulated by an electric controller to vary pump pressure and flow, providing steering efforts tailored for different driving situations. The pump can be run at low speed or shut off to provide energy savings during straight ahead driving (whic
4、h is most of the time in most world markets).Direct electric steering uses an electric motor attached to the steering rack via a gear mechanism (no pump or fluid). A variety of motor types and gear drives is possible. A microprocessor controls steering dynamics and driver effort. Inputs include vehi
5、cle speed and steering, wheel torque, angular position and turning rate. Working In Detail:A steering sensor is located on the input shaft where it enters the gearbox housing. The steering sensor is actually two sensors in one: a torque sensor that converts steering torque input and its direction in
6、to voltage signals, and a rotation sensor that converts the rotation speed and direction into voltage signals. An interface circuit that shares the same housing converts the signals from the torque sensor and rotation sensor into signals the control electronics can process.Inputs from the steering s
7、ensor are digested by a microprocessor control unit that also monitors input from the vehicles speed sensor. The sensor inputs are then compared to determine how much power assist is required according to a preprogrammed force map in the control units memory. The control unit then sends out the appr
8、opriate command to the power unit which then supplies the electric motor with current. The motor pushes the rack to the right or left depending on which way the voltage flows (reversing the current reverses the direction the motor spins). Increasing the current to the motor increases the amount of p
9、ower assist.The system has three operating modes: a normal control mode in which left or right power assist is provided in response to input from the steering torque and rotation sensors inputs; a return control mode which is used to assist steering return after completing a turn; and a damper contr
10、ol mode that changes with vehicle speed to improve road feel and dampen kickback.If the steering wheel is turned and held in the full-lock position and steering assist reaches a maximum, the control unit reduces current to the electric motor to prevent an overload situation that might damage the mot
11、or. The control unit is also designed to protect the motor against voltage surges from a faulty alternator or charging problem.The electronic steering control unit is capable of self-diagnosing faults by monitoring the systems inputs and outputs, and the driving current of the electric motor. If a p
12、roblem occurs, the control unit turns the system off by actuating a fail-safe relay in the power unit. This eliminates all power assist, causing the system to revert back to manual steering. A dash EPS warning light is also illuminated to alert the driver. To diagnose the problem, a technician jumps
13、 the terminals on the service check connector and reads out the trouble codes. click here to see a biggerElectric power steering systems promise weight reduction, fuel savings and package flexibility, at no cost penalty.Europes high fuel prices and smaller vehicles make a fertile testbed for electri
14、c steering, a technology that promises automakers weight savings and fuel economy gains. And in a short time, electric steering will make it to the U.S., too. Its just just a matter of time, says Aly Badawy, director of research and development for Delphi Saginaw Steering Systems in Saginaw, Mich. T
15、he issue was cost and thats behind us now. By 2002 here in the U.S. the cost of electric power steering will absolutely be a wash over hydraulic.Today, electric and hybrid-powered vehicles (EV), including Toyotas Prius and GMs EV-1, are the perfect domain for electric steering. But by 2010, a TRW In
16、c. internal study estimates that one out of every three cars produced in the world will be equipped with some form of electrically-assisted steering. The Cleveland-based supplier claims its new steering systems could improve fuel economy by up to 2 mpg, while enhancing handling. There are true bottom-line benefits as well for automakers by reducing overall costs and decreasing assembly time, since theres no need for pumps, hoses and fluids.An
