《辐照交联低烟无卤阻燃聚烯烃》由会员分享，可在线阅读，更多相关《辐照交联低烟无卤阻燃聚烯烃（3页珍藏版）》请在金锄头文库上搜索。
1、辐照交联低烟无卤阻燃聚烯炷电缆料Irradiation cross-linked, low-sinuke9 halogenfree and flameretardant POE compound1.产品型号.用途i. Type and application牌号Type名称Product用途及电缆规范Application and Cable SpecificationFDW1105105*C辐照交顒氐烟无卤阻燃聚烯炷电缆料 105 C Irradiation cross-linked, iow-smoke, halogen-free and flame retardant POE compo
2、und105*C交联阻燃电线电缆用绝缘、护层料105 C Insulatmg and jacket for cross-linked flame retaidant wires and cables.FDU2125125C辐照交联低烟无卤阻燃聚烯炷电缆料125 C Irradiation cross-linked, low-smoke, halogen-free and flame retardant POE compound125#C交联阻燃电线电缆用绝缘、护层料125 C Insulating and jacket for cross-linked flame retaidant wire
3、s and cables.FDW1150i5(rc辐照交联无卤阻燃聚烯桂电缆料150 C Irradiation cross-linked, low-smoke. halogen-free and flame letardant POE compound150C交联阻燃电线电缆用绝缘、护层料150 C Insulating and jacket for cross-linked flame retaidant wires and cables.FDW5105105-125X辐照交联低烟无卤高阻燃聚烯炷电缆 料105 eC Irradiation cross-linked, low-smoke,
4、 halogenfree and flame retardant POE compound105-125C交联阻燃电线电缆用绝缘、护层料， 特小规恪电线通过VW-1阻燃105 C Insulating and jacket for cross-linked flame retaidant wires aud cables. The very small grade wires could pass VW1 standard2. 产品tttg耐高温辐照交联低烟无卤阻燃聚烯炷电缆料是以聚烯炷树脂为基料，加入特殊改性剂、无卤阻燃剂、抗氧剂、交 联敏化剂等其他特殊助剂，经特殊工艺加工而制得的粒状料.i
5、i% High temperatuie resistive, irradiation cross-linked, low-smoke, halogen -free and flame retardant POE compound, based on POE resin, is produced and pelletized by special technclogy with addmg special modifier, haiogen-fiee flame retaidant, anti-oxidant, cross-linked sensibilizer and other specia
6、l additives.3、加工工艺 采用F挤出机加工,建议使用L D 20、压缩比1 : 1.2的低压缩比螺杆。iiiv ProcessingThe compound can be processed with conventional extniders. and e screw with a mimmum 20:1 L D and a compression ratio of 1.2 is recommended.推荐挤出机各区点设走溫度如下：The following【empemniie(C) piofile of extrudei is recommended区点Zone1区Zone
7、 12区Zone 23XZone 34区Zone 4机头Head模头Die溫度 temperature C90110125140145145注：如杲材料在仓库存储二个月以上,请将材料在60-70X下干燥后在使用。Note : Compound should be dried at 70-80C before use. which has storage time exceedmg two months.4、棚腳僵耐高溫辐照交联氐烟无卤阻燃聚烯炷电缆料的辐照刑建议一般为13兆拉律。iv% Irradiated dosage The normal uradiated dosage ( recomm
8、ended ) of high temperatuie resistive. irradiation cross-linked, lowsnioke. halogen-free and flame retaidant POE compound is 13 megaiad.5、包装：25kg-袋f铝塑复合薄膜抽真空内袋,牛皮纸复合袋外包装。运输与储存:电缆料在运输过程中不应受日晒雨淋,应储存在清洁、阴凉、干燥、通风的仓库内。V% Storage and transportPackaging : 25kg. bag f Vacuum Aluminum foil and PE membrane ms
9、ide bag. and kraft outside bag.Storage and uansport: Avoiding in duect sunlight and weathering The storage place should be in clean, cool, diy and ventihted conditions.6.产品ttfg （换）Vl% Properties表 Table试验项目 Item卑位 UnitFDVVU05FDW2125FDW1150FDW5105标准值 Standard典型值 Typical标准值 Standard典型值 Typical标准值 Stand
10、ard典型值 Typical标准值 Standard典型值 Typical比至 Densitygcm1.46 1.46 1.44 1.65硬度HardnessShore A 94 949286抗拉强度 Tensile Stiength MPa10015010011.010012.57.0100断裂伸长率 Elongation at Break %150170150200150180100130热老化 Theimal Aging老化温厦Aging TemperatxueC1352135215821582180x2180x21352158x2老化时间 Aging Timeh168168168168
11、1681681681687FSLetention of trengtliV7Tensile %80104801088011080104呆群RetentionofElongation at Break2 %80103809580868095热延伸：20N/cm- Thermal ProlongationCxnim200x15200x15200x15200x15载荷卞伸长率 Elongation Under Load O . mlOxlO1240xl01:1 Ox IO12OxlO12lOxlO1290xl0l:lOxlO12OxlO12介电强度 Dielectric Stiength KV in
12、m20242024202420261C111計旨数 Jxygen Index %2832283228334547氐温脆化溫度 mpact Brittleness emperatuieC-25通过Pass-25通过 Pass25通过Pass-25通过Pass烟密度有焰 Smoke Density Flaming10065100601006810045无焰 Non flanung4.36 14.35.94.35.94.36.3放出气体电导率 Conductivityofgases evolved p s/cm2.51.02.50.92.51.02.50.6The above data are all the properties of compound after cross Jinked.
