《环氧抗静电地坪面漆的用途和数据说明.doc》由会员分享，可在线阅读，更多相关《环氧抗静电地坪面漆的用途和数据说明.doc（4页珍藏版）》请在金锄头文库上搜索。
1、环氧抗静电地坪面漆的用途和数据说明Intended Uses用途用于具有抗静电要求的水泥，混凝土地板和壁墙表面涂装、如电子电器、印刷、纺织等厂车间、电器控制室，计算机房等。Suited for the floor or wall requiring anti-explosive coating. Such as electric factory, control room, compnter room, printing factory, textile miss etc.ProductInformation产品简介高固体份厚膜型环氧地坪涂料，双组份，漆膜耐磨，抗静电，哑光或高光，有限颜色。H
2、igh solid and high build epoxy floor paint, Two components with abrasion resistance, anti-static property semi-gloss or high gloss.Application details产品数据Volume Solids 体积固体份60%, Color 颜色Grey, green, blue, red and yellow etc灰、绿、蓝、红、黄等有限颜色Dry Flm Thickness干膜厚度50-200m , according to the surface conditi
3、ons50-200m ,视表面状况而定Theoretical Coverage 理论涂布率4.4-5.2 m2/kg at 100um of dry film thickness4.4-5.2平方米/公斤，以100微米干膜厚计以1mm干膜计时，为0.6-0.7 m2/kg （1.4-1.5 m2/kg ） Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗Storage and Handling施工详述Mix Radio 混合比A : B=5:1(by weight) 甲:乙=5:1Method of Application 施工方法 A
4、irless Spray 无空气喷涂 Recommended 推荐采用 Brush or Roller 刷涂或辊涂 Recommended 推荐采用Air Spray 有空气喷涂 Suitable, but diluting 10-20% is necessary 适用，但需稀释10-20%Thinner 稀释剂 C003Cleaner 油漆设备清洗剂 C003Pot Life 使用期 35：2hours; 25:4hours; 15:6hours 35：2小时; 25:4小时; 15:6小时 Storage 贮存期 one year 一年Drying time 干燥时间SubstrateTe
5、mperature底材温度Touch Dry表干（h）Hard Dry硬干(h）Fully curing完全固化 （d）3525152461224363days 天5ays 天7days 天StorageandHandling贮存与管理Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;20Kg in 20 liter container 甲:20公斤装于20公升容器中 B:4 Kg in 4 liter container 乙:4公斤装于4公升容器中Flash Point 闪点 33 （Mixture,
6、A, B） 33 (混合物、甲组份、乙组份) Specific Gravity 比重 1.15-1.35 Kg/L 1.15-1.35公斤/公升Specification and Surface preparation技术要求及表面处理All cracks, joint intersections, protrydent and hollow spots the floor have been prepared correctly and the floor has applied with primer sealer and paved with conductive copper film
7、 connecting ground,or other conducting coatings (such as conducting spackler or conducting interdiate coating) . Thus the surface must be for good effect.This product cannot cure fully at low temperature. The substrate temperature should be maintained above 10 for good effect.在涂覆本产品前，地板上所有裂纹、接缝、凸起、凹
8、陷、均已正确处理，涂装了封闭底漆并已铺设了导电铜铂接地，也可在其他导电涂层上涂装（如导电腻子或导电中途漆），确保地面和清洁干燥。本产品在低温条件下无法充分固化，为求最佳效果，底材温度应在10. 使用本产品，应现用现配，用多少配多少，并充分搅拌均匀，在使用期内用完，以免凝胶浪费。涂装此涂料，初步干燥后，即可上人，完全固化后，才能投入使用。Safety Precautions安全措施This product should be used in painting area by perfessional operators. When painting , please refer to Produ
9、ct Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying this product.参考 http:/ This product is a kind of solvent-based paint .Inorder to avoid danger or accident, minimal safety precautions,as follow , should be dow
10、n .The paint contains volatile solvent and is flammable . So must keep away from sparks and open flames.No smoking at applacation site ,Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to
11、avoid producting sparks .Flash point of paint , mentioned above on product Data sheet, is the lowest temperature at which mixture of the volatile materails of paint can ignite or explode with air. Enough ventilation is necessary at application site. In order to remove any danger of explosion, must k
12、eep the ratio of gas to air is less than 10%, the minimum explosive limit in general, Therefore, 200m3of ventilation quantuty per 1Kg solvent (according to the solvent ) is necessary.Product skin and eyes, and avoid touching with paints (Recommend to wear working clothes, gloves,eye protection, face
13、 masks barrier cream and so on ). Kif paint gets in touch with skin , wass fully with large amount of fresh water and soap or appropriate commercial cleaner. In case of eyes being contaminated, rinse with fresh water for 10min at least and give medical treatment immediately. Recommend face guard wit
14、h ventilation pipe for the sake of no absorption of paint fog and harmful solvent gas, especially in bad ventilation.Handle empty containers with care and do not bring about environmental contamination.NOTICE: If consumers have not taken effective safety precautions(Refer to the specfications), our company will NOTbe responsible for any accid
