《氟碳漆施工工艺方案》由会员分享，可在线阅读，更多相关《氟碳漆施工工艺方案（7页珍藏版）》请在金锄头文库上搜索。
1、氟碳漆施工方案氟碳金属漆涂装工艺一、流程图 施工工艺描述一 分格线1、 分格缝设置、定位、分格缝的长度、宽度、深度以及横竖方向按甲方要求进行。2、 分格缝的切割：根据分格进行切割，切割要横平竖直。分格缝切割后，用凿子剔平，并用水清洗缝内灰尘。3、 分格缝填充与修补:待批刮好粗腻子后,分次填充分格缝腻子,要深浅均匀,每次填充补前要用砂纸打磨并用水润湿分格缝,对缺脚等进行修补,做到棱角分明。4、 用圆弧形管拉成半弧形，待氟碳面漆喷完后，用羊毛刷着色。二找平腻子1、 用批刀在分割好的板块上沿水平方向满批一道腻子，用刮尺沿水平方向用力刮平，若有凹陷，则用腻子填充刮平。2、 待其完全干后，再沿垂直方向满
2、批腻子一道，然后用另一把刮尺沿垂直方向竖刮，若有凹陷，则用找平腻子填充刮平。3、 若平整度仍达不到要求，重复上述步骤，直到满足平整度要求为止。三细腻子1、 将本品的甲乙组分拌和均匀（要求再4小时内用完），必要时加适当清水调节粘度。2、 满批细腻子1-2遍，间隔的时间为4-6小时，每遍腻子层厚度约为1-2mm。3、 干燥后用180#-240#砂纸打磨腻子表面。四渗透底漆:环氧底漆N5050C54201、 将环氧底漆N5050C5420按漆：固4：1重量比搅拌均匀后，再加入适量的稀释剂调节施工粘度。可用刷涂、滚涂、喷涂。2、 用喷枪吹干净细腻子表面的浮尘，开始刷涂环氧底漆N5050C5420，先横
3、向刷涂一遍，再竖向刷一遍。3、 干燥24小时，无需打磨。五光面腻子1、 将光面腻子按比例配比混合均匀后，开始批刮。2、 满批光面腻子一遍，厚度大约为0.5mm。必要时可批刮第二遍光面腻子，但需间隔6小时。3、 施工光面腻子需干燥24小时之后采用400#砂纸打磨平整。(六)氟碳专用底漆:（氟碳中间漆U5800/C5800）1、 将氟碳中间漆U5800/C5800按漆:固12:1重量比搅拌均匀后，再加入适量的稀释剂调节施工粘度。静止5分钟消泡、熟化。可用刷涂、滚涂、喷涂。2、 调整喷枪的空气流量、出油量和喷雾幅宽，用喷枪吹干净基面的浮尘后，开始喷涂作业。3、 先横向喷涂一遍，再竖向喷涂一遍。注意喷
4、涂图形的搭接，即去枪和回枪的运行轨迹有三分之一的部分相互重叠。这样重复1-2个过程。空压机的压力应的0.2Mpa-0.5Mpa之间。4、 底漆需至少干燥24小时后，用400#-600#砂纸打磨完全平整光滑为止。(七)氟碳面漆:氟碳金属漆F5801J/C58001、 将氟碳金属漆F5801J/C5800按漆:固=15:1面漆、固化剂、稀释剂按比例混合搅拌均匀后，静止5分钟消泡、熟化，用200目的过滤网过滤到喷枪壶内。2、 调整喷枪的空气流量、出油量和喷雾幅宽，用喷枪吹干净基面的浮尘后，开始喷涂作业。3、 先横向喷涂一遍，后竖向喷涂一遍。注意喷枪图形的搭接，即去枪和回枪的运行轨迹有三分之一的部分相
5、互重叠。这样重复1-2个过程。注意事项1、 在易开裂的墙面，为了防止开裂，必须挂网。2、 找平腻子用刮尺刮两遍，使平整度小于2mm。必须严格做到。3、 腻子要注意保养和干燥时间，否则会引起水泡和开裂现象。4、 渗透底漆的漆膜不要喷涂太厚，以免影响干燥时间。渗透底漆也可以滚涂。5、 光面腻子不要一次批刮太厚，可以添加慢干稀释剂来调节干燥速度和粘度以便易于施工。6、 氟碳专用底漆的漆、固比例要掌握好，否则影响干燥速度。7、 面漆尤其金属面漆要掌握好环境温度和稀释剂的调整，应用慢干稀释剂来调整。8、 如要罩光,一定要掌握好漆固的配比比例,否则会引起色差。9、 要注意好氟碳漆整套体系中漆、固化剂和稀释
6、剂的配套。10、喷涂氟碳漆面漆时，要把架子拆掉，用吊篮喷涂作业。11、每个工地要配发一定的慢干稀释剂（VX-03），以便调整挥发速度。12、氟碳漆达到最佳效果需要养护7天，因为它是一个慢速交联过程。 成都宇华建筑工程有限公司 028-83915763 13880065868 2011-7-15 g an employment tribunal claimEmployment tribunals sort out disagreements between employers and employees.You may need to make a claim to an employment
7、tribunal if: you dont agree with the disciplinary action your employer has taken against you your employer dismisses you and you think that you have been dismissed unfairly.For more information about dismissal and unfair dismissal, seeDismissal.You can make a claim to an employment tribunal, even if
8、 you haventappealedagainst the disciplinary action your employer has taken against you. However, if you win your case, the tribunal may reduce any compensation awarded to you as a result of your failure to appeal.Remember that in most cases you must make an application to an employment tribunal with
9、in three months of the date when the event you are complaining about happened. If your application is received after this time limit, the tribunal will not usually accept it.If you are worried about how the time limits apply to you, take advice from one of the organisations listed underFurther help.
10、Employment tribunals are less formal than some other courts, but it is still a legal process and you will need to give evidence under an oath or affirmation.Most people find making a claim to an employment tribunal challenging. If you are thinking about making a claim to an employment tribunal, you
11、should get help straight away from one of the organisations listed underFurther help.If you are being represented by a solicitor at the tribunal, they may ask you to sign an agreement where you pay their fee out of your compensation if you win the case. This is known as adamages-based agreement. In
12、England and Wales, your solicitor cant charge you more than 35% of your compensation if you win the case.If you are thinking about signing up for a damages-based agreement, you should make sure youre clear about the terms of the agreement. It might be best to get advice from an experienced adviser,
13、for example, at a Citizens Advice Bureau. To find your nearest CAB, including those that give advice by e-mail, click onnearest CAB.For more information about making a claim to an employment tribunal, seeEmployment tribunals.The (lack of) air up there Watch mCayman Islands-based Webb, the head of Fi
14、fas anti-racism taskforce, is in London for the Football Associations 150th anniversary celebrations and will attend Citys Premier League match at Chelsea on Sunday.I am going to be at the match tomorrow and I have asked to meet Yaya Toure, he told BBC Sport.For me its about how he felt and I would
15、like to speak to him first to find out what his experience was.Uefa hasopened disciplinary proceedings against CSKAfor the racist behaviour of their fans duringCitys 2-1 win.Michel Platini, president of European footballs governing body, has also ordered an immediate investigation into the referees actions.CSKA said they were surprised and disappointed by Toures complaint. In a statement the Russian side added: We found no racist insults from fans of CSKA.Age has reac
