《文旅项目电气系统调试方案》由会员分享，可在线阅读，更多相关《文旅项目电气系统调试方案（59页珍藏版）》请在金锄头文库上搜索。
1、 Method Statement of Testing & Commissioning for Electrical Systems电气系统调试方案REV版本号DATE日期REASON FOR ISSUE发布原因ORIG初稿CHK审核APPR批准Privileged and Confidential机密文件目录TABLE OF CONTENTS1目的 PURPOSE42简介 INTRODUCTION42.1参考规范及标准 Reference Codes and Standards42.2定义 Definitions92.3缩略语 Acronyms and Abbreviations143工作
2、范围 SCOPE OF WORK164测试及调试流程 TESTING & COMMISSIONING PROCEDURE174.1测试前检查 Pre-Testing Inspection174.2性能测试 Performance Testing184.3文件和可交付成果 Documentation and Deliverables195测试及调试仪器 TEST & COMMISSIONING INSTRUMENT205.1工具 Tools205.2测试证书 Test Certificates216测试及调试方法 TEST & COMMISSIONING METHODOLOGY216.1低压电缆
3、测试 Low Voltage Cable Test216.1.1测试前检查 Pre-testing Check216.1.2绝缘测试 Insulation Testing236.1.3连续性测试 Continuity Testing266.2低压开关柜测试 Low Voltage Switchgear Test276.2.1测试前检查 Pre-testing Check286.2.2低压电器测试 Low Voltage Apparatus Test286.2.3低压开关柜通电测试 Low Voltage Switchgear Power-One Test306.3低压配电箱测试 Low Vol
4、tage Panelboard Test316.3.1测试前检查 Pre-testing Check336.3.2低压配电柜柜通电测试 Low Voltage Panelboard Power-One Test346.4电动机及控制柜测试 Motor and VFD/Starter Panel Test356.4.1测试前检查 Pre-testing Check356.4.2电动机及控制柜测试 Motor and VFD/Starter Panel Test366.5母线槽测试 Busway Test386.5.1测试前检查 Pre-testing Check386.5.2母线槽通电测试 Bu
5、sway Power-On Test396.6照明系统测试 Lighting System Test396.6.1测试前检查 Pre-testing Check396.6.2照明配电箱测试 Lighting Panelboard Test406.6.3照明通电测试 Lighting Power-On Test416.6.4照度及功率密度测试 Lighting Illuminance Test426.7应急照明系统测试 Emergency Lighting System Test436.7.1消防应急灯具测试 Fire Emergency Lighting Test436.7.2应急照明集中电源
6、测试 Emergency Lighting Power Test456.7.3应急照明配电箱测试 Emergency Lighting Panelboard Test466.8防雷及接地系统测试 Lightning Protection and Grounding Test476.8.1测试前检查 Pre-testing Check476.8.2接地电阻测试 Ground Resistance Test487测试及调试人员 TEST & COMMISSIONING PERSONNEL498附录 APPENDICES50附录A：电气接地电阻测试记录表 Appendix A: Grounding
7、Resistance Test Record51附录B：绝缘电阻测试记录表 Appendix B: Megger Test Record52附录C：连续性测试记录表 Appendix C: Continuity Test Record54附录D：电气器具通电检查清单 Appendix D: Electric Equipment Power-On Checklist56附录E：低压电气设备交接试验检验记录表 Appendix E: LV Electrical Equpiment Hand-Over Test Record57附录F：电气设备空载试运行记录表 Appendix F: Electri
8、cal Equipment No-Load Startup Record59附录G：照明通电试运行记录表 Appendix G: Lighting Power-On Startup Record60附录H：漏电开关模拟试验记录表 Appendix H: Leakage Current Simulation Test Record61附录I：电气线路结点测温记录表 Appendix I: Electrical Circuit Temperature Test Record62附录J：照度测试记录表 Appendix J: Illuminance Test Record63附录K：接地(等电位)联
9、接导通性测试记录表 Appendix K: Grounding (Equipotential) Continuity Test Record641 目的2 PURPOSE本调试方案将涵盖北京环球主题公园项目零售商品仓库电气系统在技术规格书260000章节，GB标准及制造商建议下的性能测试。This method statement will cover the performance testing and commissioning of Electrical Systems for Retail/Merch Warehouse, Universal Beijing Theme Park P
10、roject under the specification Section 260000, GB standard and manufacturer recommendations.3 简介4 INTRODUCTION4.1 参考规范及标准4.2 Reference Codes and Standards下列参考规范及标准将应用于电气系统的性能测试：The following references shall be used for performance testing of Electrical Systems:- GB 50054-2011 “低压配电设计规范”- GB 50054-2
11、011 “Code for Design of Low Voltage Electrical Installations”.- GB 50303-2015 “建筑电气工程施工质量验收规范”- GB 50303-2015 “Code for Acceptance of Construction Quality of Building Electrical Engineering”.- GB 50254-2014 “电气装置安装工程-低压电器施工及验收规范”- GB 50254-2014 “Code for Construction and Acceptance of Low-voltage Ap
12、paratus Electric Equipment Installation Engineering”.- GB 50150-2016 “电气装置安装工程-电气设备交接试验标准”- GB 50150-2016 “Electric Equipment Installation Engineering-Standard for Hand-over Test of Electric Equipment”.- GB 7251.1-2013 “低压成套开关设备和控制设备 第1部分:总则”- GB 7251.1-2013 “Low-voltage Switchgear and Controlgear A
13、ssemblies-Part 1:General Rules”.- GB 7251 “低压成套开关设备和控制设备”- GB 7251 “Low-voltage Switchgear and Controlgear Assemblies”.- GB 14048 “低压开关设备和控制设备”- GB 14048 “Low-voltage Switchgear and Controlgear”.- GB/T 8349-2000 “金属封闭母线”- GB/T 8349-2000 “Metal-enclosed Bus”.- JB/T 9662-2011 “密集绝缘母线干线系统（密集绝缘母线槽）”- JB
14、/T 9662-2011 “Closed Insulated Busbar Trunking Systems (Closed Insulted Busbar)”.- GB 50260-2013 “电力设施抗震设计规范”- GB 50260-2013 “Code for Seismic Design of Electrical Installations”.- GB 50149-2010 “电气装置安装工程 母线装置施工及验收规范”- GB 50149-2010 “Code for Construction and Acceptance of Busbar Installation of Electric Equipment Installation Engineering”.- JBJ 16-2008 “民用建筑电气设计规范”- JBJ 16-2008 “Code for Electrical Design of Civil Buildings”.- GB/T 14598 “电气继电器”- GB/T 14598 “Electrical Relays”.- GB 17710-2008 “设备用断路器”- GB 17710-2008 “Circuit-breaker for Equipme
