《电子动力转向系统大学毕业论文外文文献翻译及原文》由会员分享，可在线阅读，更多相关《电子动力转向系统大学毕业论文外文文献翻译及原文（18页珍藏版）》请在金锄头文库上搜索。
1、毕业设计（论文） 外文文献翻译文献、资料中文题目：电子动力转向系统文献、资料英文题目：文献、资料来源：文献、资料发表（出版）曰期： 院（部）：专 业： 班 级： 姓 名： 学 号： 指导教师：翻译曰期2017. 02. 141英文文献翻译1.1 Electronic power steering systemWhat it is：Electrically powered steering uses an electric motor to drive either the power steering hydraulic pump or the steering linkage directl
2、y. The power steering function is therefore independent ofengine speed, resulting in significant energy savings.How it works :Conventional power steering systems use an engine accessory beltto drive the pump, providing pressurized fluid that operates a pistonin the power steering gear or actuator to
3、 assist the driver.In electro-hydraulic steering, one electrically powered steering concept uses a high efficiency pump driven by an electric motor. Pump speed is regulated by an electric controller to vary pump pressureand flow, providing steering efforts tailored for different drivingsituations. T
4、he pump can be run at low speed or shut off to provideenergy savings during straight ahead driving (which is most of the time in most world markets).Direct electric steering uses an electric motor attached to thesteering rack via a gear mechanism (no pump or fluid). A variety of motor types and gear
5、 drives is possible. A microprocessor controlssteering dynamics and driver effort. Inputs include vehicle speed andsteering, wheel torque, angular position and turning rate.Working In Detail:A steering sensor is located on the input shaft where it enters the gearbox housing. The steering sensor is a
6、ctually two sensors in one: a /ztorque sensor that converts steering torque input and its direction into voltage signals, and a rotation sensor that converts the rotation speed and direction into voltage signals- An interface circuit that shares the same housing converts the signals from the torque
7、sensor and rotation sensor into signals the control electronics can process-Inputs from the steering sensor are digested by a microprocessor control unit that also monitors input from the vehicles speed sensor. The sensor inputs are then compared to determine how much power assist is required accord
8、ing to a preprogrammed force map” in the control units memory. The control unit then sends out the appropriate command to the power unit which then supplies the electric motor with current. The motor pushes the rack to the right or 1 eft depending on which way the voltage flows(reversing the current
9、 reverses the direction the motor spins).Increasing the current to the motor increases the amount of powerassist.The system has three operating modes: a normal control mode in which left or right power assist is provided in response to input from the steering torque and rotation sensors inputs; a re
10、turn control mode which is used to assist steering return after completing a turn; and a damper control mode that changes with vehicle speed to improve road feel and dampen kickback.Tf the steering wheel is turned and held in the full - lock position and steering assist reaches a maximum, the contro
11、l unit reduces current to the electric motor to prevent an overload situation that might damage the motor. The control unit is also designed to protect the motor against voltage surges from a faulty alternator or charging problem.The electronic steering control unit is capable of selfdiagnosing faul
12、ts by monitoring the systems inputs and outputs, and the driving current of the electric motor. If a problem occurs, the control unit turns the system off by actuating a fail-safe relay in the power unit. This eliminates all power assist, causing the system to revert back to manual steering. A dash
13、EPS warning light is alsoilluminated to alert the driver- To diagnose the problem, a technician jumps the terminals on the service check connector and reads out the trouble codes.ConstructionTorqu* sensor unitBall screw unit Motor unit Rack axisRack & pinion with variable gear ratioclick here to see
14、 a biggerElectric power steering systems promise weight reduction, fuelsavings and package flexibility, at no cost penalty.Europes high fuel prices and smaller vehicles make a fertiletestbed for electric steering, a technology that promises automakersweight savings and fuel economy gains. And in a s
15、hort time, electric steering will make it to the U. S., too. Its just just a matter of time, /z says Aly Badawy, director of research and development for Delphi Saginaw Steering Systems in Saginaw, Mich. The issue was cost and thats behind us now. By 2002 here in the U. S. the cost of electric power
16、 steering will absolutely be a wash over hydraulic.Today, electric and hybrid-powered vehicles (EV), including Toyotas Prius and GMs EV-1， are the perfect domain for electricsteering. But by 2010，a TRW Tnc. internal study estimates that oneout of every three cars produced in the world will be equipped withsome form of electrical1y
