Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;15Kg in 20 liter container 甲:15 公斤装于 20 公升容器中B:5kg in 5 liter container 乙：5 公升装于 5 公升容器中StorageandStorageandHandlingHandling贮存与管理贮存与管理 Flash Point 闪点 33℃ Intended Uses 用途用途适用于船底水线、水闸、水下钢结构、地下管道以及其他结构的防蚀，是一种屏蔽性较好的防锈 漆，附着力强，具有干燥迅速，能在低温条件下施工的特性，并有良好的耐水性、防腐 性、耐干 湿交替 Suited for anti-corrosive protection of ship bottom, boot toppings, sluice gate, steel and iron structure under water, underground pipeline and other iron structures. Wthe good barrier propercty. Excellent adhesion and quick dry. Available application at low temperature and good resistance to water, anti- corrosion and humid-dry cycling resistance. Product Information 产品简介产品简介银灰色，铝粉防锈漆 Silvergrey aliminium anti-corrosive paint Volume Solids 固体份≥40%Dry Flm Thickness干膜厚度40 microns equivalent to100 microns of wet film 40 微米 相当于 100 微米湿膜厚Theoretical Coverage 理论涂布率8.70 m2 /Kg 8.70 平方米/公斤Application details 产品数据产品数据Practical Coverage 实际涂布率Allow appropriate loss 允许适量损耗Mix Radio 混合比One package 单罐装Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or Roller 涂刷或辊涂 Recommended 推荐采用 Conwentional Spray 传统喷涂 Recommended 推荐采用Thinner 稀释剂 SC001Cleaner 油漆设备清洗剂 SC001Pot Life 使用期 Not limit 不限制Storage 贮存期 One year 一年Over coating Interval覆涂间隔SubstrateTemperature底材温度Touch Dry表干（h）Hard Dry硬干(h）Min 最短Max 最长Storage and Handling 施工详述施工详述Drying time 干燥时间25℃ 280℃ 24 hours 小时24℃ 8 hours 小时30℃ 6 hours 小时Not limit不限氯氯化化橡橡胶胶铝铝粉粉防防锈锈漆漆的的用用途途Specific Gravity 比重 Approx1.06 Kg/L 大约 1.06 Kg/LSpecification and Surface preparation 技术要求及表面处理技术要求及表面处理Steel surface to be painted should be shot or grit blassted to Swedish Sa2.5 or rust-removed manually with power tool to Swedish Standard St3施工钢材表面需经抛丸或喷砂处理去锈达瑞典标准 Sa2.5 级或手工、动力除锈达 St3 级Limitations 限制限制Preceding Coat: Epoxy Zinc-rich shop primer, Epoxy zinc dust shop primer, Epoxy iron-oxide red shop primer. Inorganic zinc silicate shop primer. Also directly coated on the rust-removed staal substrate.Subsequent coat: High-build chlorinated rubber iron-oxide red anti-corrisive paint, chlorinated rubber micaceous iron oxide anti-corrosive paint. High build chlorinated rubber finish, phenilic paint for boot toppings etc.前道配套涂料：环氧富锌车间底漆、环氧铁红车间底漆、无机硅酸锌车间底漆、也可直接涂覆在经过除锈的钢材上。
后道配套涂料：氯化橡胶铁红厚浆型防腐漆、氯化橡胶云铁防腐漆、氯化橡胶厚浆型面漆、酚醛水线漆等 SafetyPrecautions安全措施安全措施This product should be used in painting area by perfessional operators. When painting , please refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying this product.This product is a kind of solvent-based paint .Inorder to avoid danger or accident, minimal safety precautions,as follow , should be down .The paint contains volatile solvent and is flammable . So must keep away from sparks and open flames.No smoking at applacation site ,Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid producting sparks .Flash point of paint , mentioned above on product Data sheet, is the lowest temperature at which mixture of the volatile materails of paint can ignite or explode with air. Enough ventilation is necessary at application site. In order to remove any danger of explosion, must keep the ratio of gas to air is less than 10%, the minimum explosive limit in general, Therefore, 200m3 of ventilation quantuty per 1Kg solvent (according to the solvent ) is necessary.Product skin and eyes, and avoid touching with paints (Recommend to wear working clothes, gloves,eye protection, face masks barrier cream and so on ). Kif paint gets in touch with skin , wass fully with large amount of fresh water and soap or appropriate commercial cleaner. In case of eyes being contaminated, rinse with fresh water for 10min at least and give medical treatment immediately. Recommend face guard with ventilation pipe for the sake of no absorption of paint fog and harmful solvent gas, especially in bad ventilation.Handle empty containers with care and do not bring about environmental contamination.NOTICE: If consumers have not taken effective safety precautions(Refer to the specfications), our company will NOTbe responsible for any accident.本产品由专业人缘在工业场所使用,使用时请参照本说明书及健康安全手册,如客户在使用本产品前,未能仔细了解有关产品的健康安全知识,请与本公司联系.该涂料为溶剂型涂料,为避免事故或危险发生,应采取最低限度的安全措施如下:此涂料为易燃物,并含有挥发性易燃溶剂,,故必须远离火星和明火,严禁在作业场所吸烟,并采取有效措施,防止火星产生(如采用防爆电器设备,杜绝静电积累,避免金属撞击等)本产品说明书中所列涂料及溶剂的闪点是引起燃烧的最低温度. 施工场所应尽量进行通风良好,为消除使用过程中的爆炸隐患,应保。