《环境健康与安全培训材料》由会员分享，可在线阅读，更多相关《环境健康与安全培训材料（68页珍藏版）》请在金锄头文库上搜索。
1、Environment , Health & Safety Training Package for DLs,环境、健康与安全 培训材料 (操作工）,Quality Institute APR 2004,Page 2, Seagate Confidential,EHS Rules EHS规定,Page 3, Seagate Confidential,Contribute EHS ideas and suggestions for improvement 为共同提高积极提出对EHS的想法和建议 Report any unsafe acts or conditions for immediate
2、corrective action 为迅速改善立即报告各种不安全行为和不安全状态 Observe all EHS rules and regulations 遵守所有的EHS规章制度 Follow correct work procedures 遵循正确的工作程序,Our Pledge to EHS 我们的EHS誓言,Page 4, Seagate Confidential,No smoking in all indoor areas including 不允许在室内吸烟,包括: Toilets 厕所 Staircase 楼梯 注：室外抽烟只能在允许的指定区域进行,You are termin
3、ated. No Second Chance ! 你已被解雇了 没有第二次机会!,EHS Rules EHS规定,Page 5, Seagate Confidential,Do Not block any Safety equipment, fire alarm, fire fighting equipment and emergency exits 不要阻塞任何安全设备,防火警报,消防设备和EXIT逃生出口,EHS Rules EHS规定,Page 6, Seagate Confidential,Do Not Touch any fire callpoint, and do not affe
4、ct the smoke detector. 不要触摸手动报警器（左边）, 禁止做影响感烟探测器监测的行为（例如清扫的灰尘，施工时候烟雾，机器加热散发出来的烟）。,EHS Rules EHS规定,Page 7, Seagate Confidential,Never ride on hoist or lift which is not designed for passenger 不要搭乘载货电梯因为它不是用来载客的,EHS Rules EHS规定,Page 8, Seagate Confidential,Wrong storage 错误的存放 空瓶也需要放在化学品柜里,Store in saf
5、ety cabinet 存放在EHS批准的安全柜里,Observe proper chemical storage and disposal requirement. 遵守适当的化学品存放和处理要求（注：柜内化学品与清单一致）,EHS Rules EHS规定,Page 9, Seagate Confidential,Read the MSDS for chemical that you are handling. 在搬运、使用化学品之前仔细阅读其化学品安全技术说明书 Training should be offered before the operator use the chemical.
6、 所有的员工操作化学品之前要经过培训 Label should be offered. 所有的化学品要有标签 Wear appropriate PPE during handling. 搬运和使用化学品时佩带适当的劳动防护用品 （如IPA必须使用手套）,EHS Rules EHS规定,Using Chemical:化学品使用规程,Page 10, Seagate Confidential,EHS Rules EHS规定,Using Chemical:化学品使用规程,Operating the chemical should be on the tray. 操作化学品需要放在托盘上操作。 Sto
7、re the chemical in the chemical cabinet 使用完化学品后，将化学品瓶塞旋紧放回化学品柜里 Close chemical cabinet when it is not used. 化学品柜不用时候要关起来 Waste chemical should be used. 报废的化学品需要用正确容器装好，正确标签标识 注意：装在大容器中的化学品应储存在黄色安全柜中。,Page 11, Seagate Confidential,Health Hazard Data 健康级别 0 = normally safe 1 = slightly hazardous 2 = h
8、azardous material 3 = extreme danger 4 = deadly,Specific Hazard Data 特殊危险级别 OX = oxidizer ACID = acid ALK = alkaline COR = corrosive W = use no water e = radioactive,Flammability Data 易燃级别 Flash Points: 0 = will not burn 1 = above 200oF 2 = above 100oF; not exceeding 200oF 3 = below 100oF,Reactivity
9、 Hazard Data反应级别 0 = stable 1 = unstable if heated 2 = violent chemical change 3 = shock & heat may detonate 4 = may detonate,Page 12, Seagate Confidential,1. Check the spill source. 先确定泄漏源 2. Safety glasses and safety gloves should wear before operating. 经过培训过的人员佩戴好个人防护用品（眼镜、手套、鞋【强酸碱】方可进行操作 3. Chem
10、ical absorb material type should be select according to the source. 根据泄露源决定使用吸附棉的种类,EHS Rules EHS规定,Chemical Spill:化学品泄漏处理,Page 13, Seagate Confidential,4. First, the sock should be used. 根据泄量的多少决定使用吸附棉的方式，先用袜子状吸附绵圈起来 5. Second, pillow should be used. 再用枕头状吸附绵放到围起来的中间 6. Then use mat, and then paste
11、 waste label to the waste chemical store. 然后用片状吸附绵将地面上剩余的化学品吸附起来，最后将所有使用过的吸附绵一起放到废弃化学品收集袋中，用扎带扎紧口袋，封好袋口，贴好标签，根据化学品废弃丢弃原则丢进化学品库报废区,EHS Rules EHS规定,Chemical Spill:化学品泄漏处理,Page 14, Seagate Confidential,When using pen-knife, Cut away from you 使用削笔刀时，从你自己近处往远处切割，注意另一只手 USE appropriate cutters，do not use
12、the blade. 使用恰当的刀具，不要使用没有外壳的刀片 DO NOT expose the cutting blade more than necessary for the jop 伸出刀片的长度不要太长 Always retract the cutting blade when not in use 当不使用时请缩回刀片 Do not put the finger in the path that the cutter pass. 不要将手放在刀经过的地方,EHS Rules EHS规定,Using cutters:使用刀具,Page 15, Seagate Confidential
13、,If drive is jammed , DO NOT attempt any repairing or un-jamming. Ask for qualified persons help. 如果drive被卡住了, 未被培训如何处理，不要试图做任何修理或自 己拿出来,寻求有资格的人员的帮助,WHO ?,Im qualify and train for the job. Leave it to me ! 我是有资格的并且已经被培训过了.让我来做!,EHS Rules EHS规定,Page 16, Seagate Confidential,Do not force your way pass
14、 other people. Let them know that you are coming through, and request them to clear the path. 不要强行穿过人群,让他们知道你要通过,并让他们让一条路出来,Do not push more than one trolley at one time. 每次都不能推超过一辆的小车,Excuse Me, I need to access the way. 对不起,我想通过这条路,EHS Rules EHS规定,When push the trolley：在推小车的时候,The material can not
15、 block the sight. 物料不可以挡住视线,Do not put the leg in the wheel. 不要将脚放到可能压到脚的轮子边上,Page 17, Seagate Confidential,Prevent Slips, Trips and Falls 防止滑倒,跌倒和摔倒,I will walk carefully when the cleaners are mopping/polishing the floor 在清洁工拖地/磨地板的时候我要小心的走,I will not use the courtyard to go to the canteen when it
16、is raining 当下雨的时候我不会走到外面去,I will be careful when boarding and alighting from the bus 从汽车上下来的时候我会小心一点,I will not rush from one place to another 我不会从一个地方冲到另一个地方,EHS Rules EHS规定,Page 18, Seagate Confidential,EHS Rules EHS规定,When using the staircase orescalator当用楼梯或电梯时:,Hold on to the handrail at all times 任何时候上下楼梯时都要扶住栏杆 Always face the direction you are travelling 上下楼梯时时刻注意前方 Do not rush, run or skip 不要有冲、跑、蹦跳的动作 Do not carry bulky lo
