《圆柱电池18650--1800-2p规格书》由会员分享，可在线阅读，更多相关《圆柱电池18650--1800-2p规格书（9页珍藏版）》请在金锄头文库上搜索。
1、FN NO/文件编号：M18650C-3600mAh版本 A1深孚众望竭尽所能Page 1 of 9 Li-ion Cylindrical Battery Specification 锂离子圆柱电池说明书锂离子圆柱电池说明书 MODEL 型 号:M18650 电池组 NominalCapacity 标 称 容 量:3600mAh Customer 客户: Total Page 文件页数：9 Registered 编制 Checked 审核 Approved 批准 王飞跃王飞跃 2014.03.24 厂址：江苏省扬州市邗江工业区牧羊路 58 号孚能科技园 总部：上海市浦东新区浦电路 266 号陆
2、家嘴投资大厦 10 层 D 单元 办事处（深圳） ：深圳市龙华新区大浪华辉路同胜科技大厦 A 座 10 层 Tel：+86 75523063186/23028086Fax：+86 755 23063189 Web：/E-mail: CustomerApprove 客户确认 Dept. 部门 Signature 签名 Date 日期 QA Dept 品质 R又 搁置 10 分钟,重复以上步骤,直到放电容量是初始容量的 80% 300 times(次) 5.3 Capability of keeping electricity 荷电保持能力 205, After standard charging
3、, rest the battery 28days, discharging at 0.2C to voltage 3.0V, recording the discharging time. 在 205状态下,标准充饱电后,电芯搁置 28 天,然后用 0.2C 放电至 3.0V,所记录放电时间. 240min 6Environment Performance环境性能环境性能 No.Item 项目Test Methods and Condition 测试方法和条件Criteria 标准 6.1 Discharge at high temperature 高温放电 After standard c
4、harging, rest the cells 4h at 60 2, then discharging at 1C to voltage 3.0V, recording the discharging time. 标准充电后，在 602条件下贮存 4h，然后用 1C 放电至 3.0V,所记录放电时间. 54min 6.2 Discharge at low temperature 低温放电 After standard charging, rest the cells for 16h at -202, then discharging at 0.2C to voltage 3.0V, reco
5、rding the discharging time. 标准充电后， 在-202条件下贮存 16h， 然后用 0.2C 放电 至 3.0V,所记录放电时间. 210min 6.4 Thermal shock 热冲击 Put the cells in the oven. The temperature of the oven is to be raised at 52per minute to a temperature of 1302and remains 30 minutes. No fire, no smoke 不起火,不冒烟 FN NO/文件编号：M18650C-3600mAh版本 A1
6、深孚众望竭尽所能Page 7 of 9 将电池放进烘箱内, 以 52/min 速度升高烘箱内温度至 1302后,恒温 30min. 7Safe Characteristic安全性能安全性能 No.Item 项目Test Methods and Condition 测试方法和条件Criteria 标准 7.1 Over charge testing 过充测试 At 235, charging cells with constant current 3C to voltage 5.0V, then with constant voltage 5.0V till current decline to
7、 0. Stop test till cells temperature 10lower than max temperature. 在 235状态下,电池用 3C 电流充电至 5.0V,然后恒压 5.0V让电流下降接近为 0A,监视电池温度变化,当电池温 度下降一峰值低约 10时,停止实验. No smoke or fire 不起火,不冒烟 7.2 Over discharge testing 过放测试 At 23 5 ,According to the requirements of standard charge, the cells will be discharge to cut-o
8、ff voltage, then connect with external load of 30 ohm for 24 hours. 在 235状态下, 按标准放电的要求放电至终止电压 后,外接 30负载放电 24 小时. No fire, no smoke, no leakage. 无起火,无冒烟,无泄 液 7.3 Short-circuit testing 短路测试 At 23 5, After standard charging, connect cells anode and cathode by wire which impedance less than 50m , keep 6
9、h. 在 235状态下,标准充电后,将电池的正负极用一根 小于 50m的导线连接,放置 6 小时. No smoke or fire不起 火,不冒烟 Above testing of safe characteristic must be with protective equipment.(安全性能测试应在有保护措施下进行) 8. CAUTIONS IN USE 使用警告使用警告 To ensure proper use of the battery please read the manual carefully before using it. Handling 为了使电池安全的使用及处
10、理请在使用前认真的阅读操作说明 Do not expose to, dispose of the battery in fire. 不能把电池曝晒或丢在火中 Do not put the battery in a charger or equipment with wrong terminals connected. 电池充电时不能把正负极性装反 Avoid shorting the battery 避免短路电池 Avoid excessive physical shock or vibration. 避免过分的物理震动和冲击电池 Do not disassemble or deform th
11、e battery. 不能拆解或使电池变形 Do not immerse in water. 不能将电池浸入水中 Do not use the battery mixed with other different make, type, or model batteries. 不能将其它不同厂家，类型，型号的电池混合使用 Keep out of the reach of children. FN NO/文件编号：M18650C-3600mAh版本 A1深孚众望竭尽所能Page 8 of 9 禁止小孩接触电池 charge and discharge 充放电 Battery must be ch
12、arged in appropriate charger only. 电池必须在合适的条件下充电 Never use a modified or damaged charger. 决不能用故障的充电器给电池充电 Do not leave battery in charger over 24 hours. 电池持续充电不能超过 24H . storage 贮存 Store the battery in a cool, dry and well-ventilated area. 电池贮藏在通风干燥的环境中 .disposal处理 Regulations vary for different cou
13、ntries.Dispose of in accordance with local regulations. 不同国家法规的不同，处理时根据当地的法规。 9.Battery operation instruction 电池操作说明电池操作说明 9.1Charging 充电 Charging current：Cannot surpass the biggest charging current which in this specification book stipulated。 充电电流：不能超过规格书规定的最大的充电电流 Charging voltage：Does not have to
14、 surpass the highest amount which in this specification book stipulated to decide the voltage。 充电电压：不能超过规格书规定的最高的限制电压 Charge temperature ： The battery must carry on the charge in the ambient temperature scope which this specification book stipulated。 充电温度：电池充电温度必须按照规格书的温度范围执行 Uses the constant elect
15、ric current and the constant voltage way charge, the prohibition reverse charges. If the battery positive electrode and the cathode meet instead, can damage the battery。 先恒流后恒压方式充电，禁止颠倒的方式充电。如果电池正负极颠倒充电会带来危险。 9.2Discharging current 放电电流 The discharging current does not have to surpass this specifica
16、tion book stipulation the biggest discharging current, the oversized electric current electric discharge can cause the battery capacity play to reduce and to cause the battery heat。 电池放电电流不能超过规格书规定的最大放电电流，过大的电流放电会造成电池发热和容量衰减。 9.3discharge temperature 放电温度 The battery discharge must carry on in the ambient temperature scope which this specification book stipulated 电池放电温度必须按照规格书的温度范围执行 9.4Over-disc
