《蒂森电梯变频器调试.pdf》由会员分享，可在线阅读，更多相关《蒂森电梯变频器调试.pdf（76页珍藏版）》请在金锄头文库上搜索。
1、? ? CPIK?Frequency?Inverter? ? Operating?Manual? ? Non-Regenerative? 11M 15M 32M 48M 60 105? 15RM 32RM 48RM? Regenerative? 25R 33R 50R 100R 150R? ? A?company?of? ThyssenKrupp? Elevator? ThyssenKrupp?Elevator?(Korea)? OPERATING MANUAL ThyssenKrupp?Elevator?(Korea)? i Printers imprint All rights reser
2、ved Copyright by: ThyssenKrupp Elevator (Korea) Ltd. 55-30, Oryu-dong, Kuro-Ku, Seoul Printed in Korea, September 2006 The right of reprint or reproduction, even in the case of only partly exploitation, is subject to express, written permission of ThyssenKrupp Elevator (Korea) Ltd Any reproduction,
3、copying or storing in data processing machines in any form or by any means without prior permission of ThyssenKrupp Elevator (Korea) Ltd. is regarded as infringement of the current Copyright Act and will be prosecuted. Technical modifications for reasons of improvement or higher safety standard are
4、subject to decisions of ThyssenKrupp Elevator (Korea) Ltd. without prior notice. The responsibility for the content lies with the editor: ThyssenKrupp Elevator (Korea) Ltd. Preface We are pleased that you decided to purchase a quality product from ThyssenKrupp Elevator (Korea) Ltd. This operating ma
5、nual assists you in getting familiar with the frequency inverter and its intended possibilities of use. Important information concerning safety and hazards helps you to safely use the frequency inverter as intended. Subject to technical alteration. ? ? OPERATING MANUAL ThyssenKrupp?Elevator?(Korea)?
6、 ii TABLE?OF?CONTENT? ? 1.?SAFETY?1? 1.1?Explanation?of?symbols?used.?1? 1.2?General?safety?information?2? 2.?PRODUCT?DESCRIPTION?AND?INSTALLATION?INSTRUCTIONS.?5? 2.1?Representation?of?frequency?inverter?CPIK.?5? 2.2?Description?of?frequency?inverter?CPIK?6? 2.2.1?Warnings?6? 2.2.2?Mounting?instruc
7、tions.?7? 2.2.3?Technical?data?8? 2.2.3.1?General?data.?8? 2.2.3.2?Type?specification.?9? 2.2.3.3?External?modules?10? 2.2.3.4?Derating?10? 2.2.4?General?instructions.?10? 2.2.4.1?Mains?voltage.?10? 2.2.4.2?System?configuration.?11? 2.2.4.3?Mains?connection.?11? 2.2.4.4?Isolation?of?frequency?invert
8、er.?11? 2.2.4.5?Leakage?current?11? 2.2.4.6?Fault?current.?11? 2.2.4.7?Discharge?time?of?DC?link?capacitors?11? 2.2.4.8?Electronic?ground?11? 2.2.4.9?Run?Contactor.?11? 2.2.4.10?Internal?fan?11? 2.3?Interface.?12? 2.3.1?Connection?diagram.?12? 2.3.2?Frequency?inverter?Input?and?Output?terminals?(Non
9、-Regenerative).?12? 2.3.2.1?Mains?12? 2.3.2.2?Motor?and?Cables.?12? 2.3.2.3?Braking?resistor?12? 2.3.2.4?Internal?voltage.?12 2.3.2.5?Separately?driven?motor?fan.?13 2.3.2.6?Motor?PTC?thermistor?connection.?13 2.3.2?Frequency?inverter?Input?and?Output?terminals?(Regenerative).?13 ? ? ? ? OPERATING M
10、ANUAL ThyssenKrupp?Elevator?(Korea)? iii TABLE?OF?CONTENT? 2.3.2.1?Mains?13 2.3.2.2?Motor?and?Cables.?13? 2.3.4?Encoder?connection?and?CAN?communication?14? 2.3.4.1?Encoder?connection.?14? 2.3.4.2?Encoder?signals?and?CAN?communication?to?control.?14? 2.3.4.3?Using?the?CAN?interface?to?connect?the?TC
11、M?(or?TAC50K)?control?system?14? 2.3.4.4?Switching?sequence?chart?with?TCM?control?16? 2.3.4.5?Switching?sequence?chart?with?TAC50K?control.?17? 2.3.5?Interface?to?the?lift?control.?18 2.3.5.1?Ready?message.?18 2.3.5.2?Inputs?and?outputs?18 2.3.5.3?Switching?sequence?chart.?19 2.4?System?perturbatio
12、ns,?EMC.?20 2.4.1?General?20 2.4.2?Mounting?Instructions.?20 2.4.3?Line?choke?20 2.4.4?Line?filter?20 2.4.5?Installation?of?other?cables?20 2.5?Dimension?sheet?21 2.5.1?Dimension?of?CPIK?series?21 2.5.2?External?modules.?22 2.5.2.1?DC?choke.?22 2.5.2.2?Line?filter?(standard,?not?used?IT?lines).?23 2
13、.5.2.3?Line?choke?25 3.?TRANSPORT?AND?STORAGE.?2 2 2 26 6 6 6 ? ? 3.1?General?26 4.?PUTTING?INTO?OPERATION?2 2 2 28 8 8 8 ? ? 4.1?Safety?instructions.?28 4.2?Operating?instructions?28 4.3?Points?to?be?observed?prior?to?initial?powering?on?28 4.4?Checking?the?visual?displays?in?the?event?of?errors?28
14、 4.5?Input?of?lift-specific?values.?29 4.6?Testing?the?drive?for?correct?functioning.?29 4.7?Drive?optimization?30 4.8?Measuring?and?setting?31 4.8.1?LED?and?measuring?points?on?TMI2?board?31 4.8.2?LED?and?measuring?points?on?RMC?board?32 4.8.3?LED?and?measuring?points?on?RMBK?board?(Regenerative?ty
15、pe).?33 ? OPERATING MANUAL ThyssenKrupp?Elevator?(Korea)? iv TABLE?OF?CONTENT? 5.?PARAMETER?ENTRY.?3 3 3 34 4 4 4 5.1?General?34 5.2?Operation.?34 5.2.1?Display?and?change?of?parameters.?34 5.2.2?Display?parameters?35 5.2.3?Save?changed?parameters?to?EEPROM.?35 5.2.4?All?parameters?as?factory-set?35
16、 5.2.5?Individual parameters as factory-set?36 5.3?Error?stacks.?36 5.3.1?Display?error?stack.?36 5.3.2?Delete?error?stack?36 5.3.3?End?error?stack?36 5.3.4?Error?description?36 5.4?Parameters.?36 5.4.1?Variable?parameters.?36 5.4.2?Display?parameters?45 6.?SHORT-RUN?DEVICE?4 4 4 48 8 8 8 6.1?General?48 6.2?Settings?48 7.?MODERNIZATION.?50505050 7.1?General?50 7.2?Modernization?by?encoder?mounted?on?motor?shaft?50 7.2.1?Rating?50 7.2.2?Motor?adaptation.?50 7.
