《磁性分离器选型及中英说明书》由会员分享，可在线阅读，更多相关《磁性分离器选型及中英说明书（10页珍藏版）》请在金锄头文库上搜索。
1、磁性分离器 Magnetic separator 说明书(The instructions) 中 国 (CHINACHINA) 烟台科诺机床辅助设备有限公司 Yantai Kenoll Machine Auxiliary Equipment CO., LTD 使 用 说 明 书 一. 用途: 磁性分离器是清除液体中可被磁化的固体粒 子的理想设备,如用于磨床及其它机床冷却液(切 削液或乳化液)的净化。 通过分离器的磁性滚筒把冷却液中的铁屑吸 出,使冷却液保持干净,使用磁性分离器可以减少 砂轮修正次数,提高加工件表面粗糙度,延长砂轮 和冷却液的使用寿命,同时减轻了工人劳动强度, 减少了废冷却液对环
2、境污染。 OPERATION INSTRUCTIONS The magnetic separator is the ideal equipment for cleaning up solid particles that may be magnetized from liquid, such as purification of cooling agent (cutting oil or emulsion) used in a grinder and other machine tools. Iron fillings are absorbed from cooling agent by ma
3、gnetic roll of separator, to keep the cooling agent clean, By using of the separator, times of correcting grinding wheel will be rise, the smooth finish of work pieces will be rises, life of grinding wheel and life of cooling agent will be prolonged, the working hardness and the pollution of environ
4、ment caused by waste cooling agent will be lowed greatly. 二.结构原理及安装尺寸 磁性分离器由减速器和磁辊两大部分组成。减 速器是通过链条带动磁辊转动,磁辊内装有永久强 力磁铁,冷却液中的铁屑吸附在磁鼓套表面,压辊 将铁屑中的冷却液挤压出去,并流回液箱,铁屑被 刮板刮掉后排入污物箱。 STRUCTION AND DIMENSION The magnetic separator is consisted of reduction and magnetic roll. Reductions drive the magnetic roll b
5、y chain. The magnetic roll with many pieces of permanent magnetic can attract iron particle from cool liquid and make iron particles on the surface of it. Cooling liquid contained in iron fillings is then extruded out by press of magnetic roll and return to liquid tank . Iron filling scraped by rubb
6、er fall into dirt box. + 三.型号规格及性能(见表1.表2) MODEL AND PERFORMANCE 表 1 名名 称称 NameName 流量流量( (升升/ /分分) ) Flows l/minFlows l/min 磁辊转速磁辊转速( (转转/ /分分) ) Nom of magnet drum Nom of magnet drum l/minl/min 电机功率电机功率 Power of motorPower of motor 瓦瓦(W)(W) 电机转速电机转速 Nom of motorNom of motor ( (转转/ /分分) ) XYCFXYCF-
7、 -25 25 2525 3 3 2525 14001400 XYCFXYCF- -5050 5050 3 3 2525 14001400 XYCFXYCF- -100100 100100 3 3 4040 14001400 XYCFXYCF- -200200 200200 3 3 4040 14001400 XYXYCFCF- -3 30000 300300 3 3 4040 14001400 表 2 名称 宽度尺寸 长 度 尺 寸 高度尺寸 接口尺寸 A B C D E F G 入 水 口 出 水 口 XYCF-25 295 275 320 290 265 165 110 2” 80 XY
8、CF-50 360 240 320 290 265 165 110 2” 80 XYCF-100 490 470 400 370 300 185 115 3” 150 XYCF-200 620 600 400 370 300 185 115 3” 150 XYCF-300 750 730 400 370 300 185 115 3” 150 四.使用安装 1. 磁性分离器的流量应根据机床水泵流量选定,两 者应相一致。 2. 运行中,磁辊的转向应按图 1 箭头所示。 3. 胶辊的松紧调整适当,用来挤压铁屑中的水分。 4. 刮板的位置也可调整,不要与磁辊靠的太紧,用来刮除磁辊上的铁屑。 OPERA
9、TION AND INSTALLTION 1.The flow capacity of the magnetic separator should be selected according to the flow capacity of pump, the both are asked to be same. 2.In operation, the direction of the magnetic rolls rotation should accord with arrow see fig.1 3 3.Tightness of rubber pressing magnetic roll
10、is adjustable to press water contained in iron filling. 4.The position of scraping board is adjustable not too close to magnetic roll, to scrape iron filling on the surface of magnetic roll. 五.保养与润滑 减速机的保养详见说明书,磁性分离器的转动部位均采用球轴承润滑脂润滑。 名称 型 号 数量 安装位置 球轴承 6004 GB/T 276-1994 2 胶辊 球轴承 UCF204 2 磁辊 链条 P=12
11、.7 1 链盒 MAINTENANCE AND LUBRICTION The main tenant of reduction is on manual, the ball bearings in magnetic separator should be lubricated with grease. 五.附图(drawing:) 合 格 证 明 书 CERTIFICATE 型号规格 Model 本产品按标准检验合格准予出厂 This filter has been tested and proved to be qualified for ex-work 检查员Inspector 检查科长
12、Chief of Inspection Dept 厂 长 Director of Factory 中 国 (CHINACHINA) 烟台科诺机床辅助设备有限公司 Yantai Yantai KenollKenoll M Machine achine A Auxiliary uxiliary E Equipment quipment COCO., LTD., LTD 装 箱 单 (PACKING LIST) 序 号 名 称 数 量 备 注 Item No Description Quantity Note 1. 技术文件 1 份 Technical document 1 Part 2. 使用说明书 1 份 Operation instruction 1 Part 3. 合格证明书 1 份 Certificate 1 Part 4. 装箱单 1 份 Packing list 1 Part 装箱检查员Packing inspector 批 号Serial No
