《pall超纯水机配件安装维修和原理介绍(英文版)》由会员分享，可在线阅读，更多相关《pall超纯水机配件安装维修和原理介绍(英文版)（24页珍藏版）》请在金锄头文库上搜索。
1、Service ManualCascadaTMLab Water SystemsIX-water ModelLS-water ModelSERVICE MANUAL Cascada IX and LS Lab Water Systems 100 to 240 VAC 50 to 60HzForewordFOREWORDThis service manual has been prepared for the Cascada IX-water and LS-water Systems.Part NumberDescriptionCountryPAL-CAXXXIXM2Cascada IX-Wat
2、erAmericas, SystemChina, AsiaPAL-CASXXIXM1Cascada IX-WaterEurope, Japan SystemPAL-CAXXXLSM2Cascada LS-WaterAmericas. SystemChina, AsiaPAL-CASXXLSM1Cascada LS-WaterEurope, Japan SystemThis manual is intended to be used by properly trained and authorized service engineers in conjunction with the Casca
3、da Lab Water System Operation Manual for the IX-water and LS-water models (PN MANU38437 Version 2, November 2006).TABLE OF CONTENTS INSTRUCTIONS1Users Responsibility1Electrical1Pressure1Ultraviolet (UV) Light2Sanitization Chemicals2Control of Substances Hazardous to Health (COSHH) 2PAL-C100 Sanitiza
4、tion Tablet Safety Information2ROUTINE SERVICE3TROUBLESHOOTING4CALIBRATION PROCEDURE5Microprocessor PCB - Location of Test and 6 Level Control Links CASCADA IX-WATER AND LS-WATER 8 SYSTEM PARTS LISTInlet Parts Location, Front View - 10 Cascada IX-water SystemParts Location Nearest the Pump - 11 Casc
5、ada IX-water SystemInlet Parts Location, Front View12 Cascada LS-water SystemParts Location Nearest the Pump - 13 Cascada LS-water SystemDispense Assembly13Cartridge Connector14Line Cell and Thermistor14Inlet Sub-assembly14UV and UF Locations15SYSTEM WIRING DIAGRAM16KEY TO CONTROL PANEL17Icons17Alar
6、m Conditions17Quality Alarms17REMOTE ALARM OUTPUT CONNECTION18 WARRANTY/CONDITIONS OF SALE19Table of Contents1SAFETY INSTRUCTIONSDo not attempt to operate or maintain the system without first reading this manual.The basic rules of safety set forth in this manual are intended as a guide for safe oper
7、ation of Pall Corporation equipment. This general safety information, along with explicit service, maintenance, and operational materials for the specific machine, make up the complete instruction manual. All personnel who will operate, service, or be involved with this equipment in any way should b
8、e completely familiar with this information prior to start-up. It is the users responsibility to make certain that the procedures set forth are followed.The Cascada Lab Water Systems have been designed to be safe; however, it is important that personnel working on these units understand any potentia
9、l dangers. All safety information in this manual is highlighted as WARNING and CAUTION instructions. These are as follows:WARNING!WARNINGS ARE GIVEN WHERE FAILURE TO OBSERVE THE INSTRUCTION COULD RESULT IN INJURY OR DEATH TO PERSONS.CAUTION!Cautions are given where failure to observe the instruction
10、 could result in damage to the equipment, associated equipment, and processes.Users ResponsibilityIt is essential that the power switch on the Cascada Lab Water System is turned off before any items are changed or maintenance work performed.The On/Off switch is located at the left-hand side of the u
11、nit. The main power cord is located just behind the On/Off switch.WARNING!THIS APPLIANCE MUST BE GROUNDED. PLUG INTO A PROPERLY GROUNDED (GFI) WALL OUTLET.ElectricalPower socketMain Power SupplyFuses On/Off power switchPower cordPressureThe main water supply valve should be turned off and residual p
12、ressure released prior to removal of any cartridges or carrying out work on the unit.CAUTION!Switching off the electrical power will isolate the source of pressure, but pressure trapped within the unit should be released.SAFETY INSTRUCTIONS the sanitization cycle, a PAL-C100 sanitization tablet is u
13、sed and relevant safety information is included in this manual. A safety data sheet conforming to COSHH and/or OSHA regulations is also provided with the tablets and should be read before a tablet is used.Sanitization ChemicalsUltraviolet (UV) LightWARNING!UNDER NO CIRCUMSTANCES SHOULD THE LAMP BE C
14、ONNECTED AND ACTIVATED WHEN OUTSIDE THE HOUSING.The Cascada LS-water unit is fitted with a UV lamp. The UV lamp is enclosed in a stainless steel chamber ensuring that the operator will not be exposed to UV light.The Cascada IX-water unit does not contain a UV lamp.Cascada LS-water Unit with UV LampU
15、V lampPAL-C100 Sanitization Tablet - Safety InformationGeneral description: White, solid tablet which rapidly dissolves in water and is used for sanitization applications.Hazard assessment: Contains sodium dichloroisocyanurate dihydrate and is toxic by inhalation, ingestion, and skin contact.Propert
16、ies: Soluble in water and pH 6, non-combustible. Handling precautions: Keep container tightly closed in a dry place and wear protective clothing when handling.Spillages: If tablets are dry and uncontaminated, gather and place in heavy duty, plastic bag. Do not return to original container. Wash away any residues with copious amounts of water.Toxicity: Serious risk of poisoning by inhalation or ingestion. Irritating to skin,
