《yzp系列样本》由会员分享，可在线阅读，更多相关《yzp系列样本（14页珍藏版）》请在金锄头文库上搜索。
1、YZP系列变频调速三相异步电动机YZP series frequency speed control three-phase asynchronous motor1.概述YZP系列冶金及起重用变频调速三相异步电动机，用于驱动各种型式的起重机械及其他类似设备的专用产品；是以变频调速装置为供电电源的专用电动机。能与国内外各种变频装置配套，组成变频调速系统。电动机调速范围广、过载能力强、运行稳定、可靠、效率高。因此，它特别适用于那些短时或断续运行，频繁地起动、制动、有时过负荷及显著振动与冲击的设备。2、使用条件海拔不超过1000m能正常运行。F级适用于环境空气温度在-20到40之间，H级适用于环境空
2、气温度在-20到60之间。相对湿度小于90%。3、基本型式标称电压：380V 基 频：50Hz，1-50Hz恒转矩调速，50-100Hz恒功率调速 防护等级：IP54 绝缘等级：F级或H级冷却方式：风机冷却（IC416）基准工作制：S3-40%安装方式：B3（112400）、B5（112250）、V1（112315）、B35（132315）定子接线方式：160及以下电机定子绕组为Y接法；180及以上电机定子绕组为接法注：根据用户要求，可带超温保护开关、防潮加热带、电磁制动器、编码器及超速开关等，可根据用户要求提供基频50Hz以下的电机。4、冷却风机型式标称电压：380V 基 频：50Hz 基准
3、工作制：S1对应机座号的轴流风机功率见表1表1 对应机座号的轴流风机功率 (Table1 Number of frame and fan power)机座号Number of frame112132160180200225250280315355400450轴流风机功率Drive motor of fanOutput power (W)9040808015020023023035060011001100注：根据用户要求，可采用用离心风机的冷却.对应机座号的离心风机功率见表2表2 对应机座号的离心风机功率 (Table2 Number of frame and centrifugal fan p
4、ower)机座号Number of frame132160180200225250280315355400450风机型号type of centrifugal fanL-04L-05L-06L-064L-08L-11风机电机功率power of centrifugal fan motor60W180W370W1.1 kW35.5kW风机电机极数pole of centrifugal fan motor222224风机必须由独立电源供电。1. GeneralYZP series VVVF adjustable speed motors for metallurgy and crane are s
5、pecially used for driving various cranes and other similarity equipment. The YZP series use frequency conversion adjustable speed power and can be used with various variable frequency units at home and abroad. The YZP series have wide adjustable speed range, high overload capacity, high reliable, hi
6、gh efficiency. The YZP series are very suitable the machine which frequency start and stop or interrupted duty with starting, braking, inverse frequently.2. Operation conditionThe motor can run normally when the elevation not more than 1000m. The environment temperature for class F is from -20 to 40
7、 Celsius degree，for H class from -20 to 60 Celsius degree. Relative humidity less 90%.3. Base moderated voltage: 380V. base frequency: 50Hz，1-50Hz constant torque adjustable speed, 50-100Hz constant power adjustable speedprotection Class:IP54 insulation class: F or Hcooling mode: fan cooling（IC416）b
8、ase operating duty : S3-40%install mode: B3（112450）、B5（112250）、V1（112315）、B35（132315）winding connection: Y to 160 and below; to 180 and aboveAccording to the agreement, the following are optional: over-temperature protection, dampproof heating belt, brake, rotary encoder, over-speed switch.4 Cooling
9、 fan Rated voltage: 380V. Base frequency: 50Hz，Base operating mode : S1According to the demand of customer, we can provide centrifugal fan.The power of drive motor shown in table1 and table 2.Fan must be powered independently!5. YZP系列变频调速电动机型号意义：Significance of models of YZP series frequency (speed)
10、 motor Y Z P 160 L - 4 异步电机 极数 Asynchronous motor Number of poles冶金及起重用 机座长短代号For metallurgy and lifting Long and short code of frame变频调速 中心高（mm）Frequency conversion and Height of center (mm) speed adjustment 注：电机带带风机、制动器或编码器，则其型号加上其对应的符号。Note: In case that the motor is equipped with fan moter、brake
11、 or rotary encoder, the corresponding characteristic 6. 变频电机基准工作制为S3-40%，280及以下中心高其它工作制功率换算关系见表3，315及以上中心高其它工作制功率换算需与厂家联系表3 工作制功率换算关系(Table 3 duty and power)工作制dutyS1S2S3S4100%30 minutes60 minutes 15%25%40%60%150 times/hour 300 times/hour 功率折算关系Conversion relation of powerr1.001.101.001.351.101.000.
12、800.830.736.The base duty of the frequency conversion motor is: S3-40%, the conversion relation with other characters of service is as table 3:7. YZP系列电机主要技术参数：Main technical parameters of YZP series motor (only for reference, see the nameplate of the motor for details): 电机为4极表（1）motor with four pol
13、es (table 1)型号model标称功率nominal power (kw)额定电流rated current (A)额定转矩rated torque (N.m)额定转速rated speed (r/min)堵转转矩/额定转矩rated torque / locked rotor torque (1Hz) 最大转矩/额定转矩rated torque / max. torque (50Hz)转动惯量moment of inertia kgm2重量weight (kg)YZP100L2-42.261513901.522.90.016535YZP112M1-42.261513901.523.00.017050YZP112M2-438.020.514001.523.00.017353YZP112M3-44.09.52714151.523.00.017555YZP132S-45.512.23614501.523.10.04878YZP132M-47.516.94814501.523.20.05692YZP160M1-4 7.516.9
