《【2017年整理】氯化橡胶中涂面漆的用途》由会员分享，可在线阅读，更多相关《【2017年整理】氯化橡胶中涂面漆的用途（3页珍藏版）》请在金锄头文库上搜索。
1、Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;25Kg in 20 liter container 甲:25 公斤装于 20公升容器中Flash Point 闪点 23 高于 23StorageandHandling贮存与管理Specific Gravity 比重 Approx1.2Kg/L 大约 1.2 公斤/公升Intended Uses用途氯化橡胶漆，设计用于喷漆施工，其用途包括：用于中度恶劣环境下的钢材保护涂料，内墙和天花板保护涂料，具有抗均性和部分耐化学品性，可低温涂装Chlorinated
2、 rubber paint.designed for spray application. Its use covers: protective paint for steel, interior wall and ceiling under moderately abominable conditions. This product posessed fungus resistance to some chemicals can be applied at low temperature. ProductInformation产品简介单罐装,厚膜型氯化橡胶漆，用作中涂漆或面漆，无空气喷涂施工
3、One package, high-build chlorinated rubber paint, used as intermediate coat or finish, Airless sprayVolume Solids 固体份 45%Dry Flm Thickness 干膜厚度 50microns 50 微米Theoretical Coverage 理论涂布率 7.5m2 /Kg 7.5 平方米/公斤Application details产品数据Practical Coverage 实际涂布率 Allow appropriate loss 允许适量损耗Mix Radio 混合比 One
4、 pack 单罐装Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or Roller 涂刷或辊涂 Recommended 推荐采用Conwentional Spray 传统喷涂 Not Recommended 不推荐使用Thinner 稀释剂 SC001Cleaner 油漆设备清洗剂 SC001Pot Life 使用期 Not limit 不限制Storage 贮存期 One year 一年Over coating Interval覆涂间隔SubstrateTemperature底材温度Touch Dry表
5、干（h）Hard Dry硬干(h） Min最短 Max最长Storage and Handling施工详述Drying time 干燥时间52335210.524888 hours 小时4 hours 小时2 hours 小时Indefinite不定氯 化 橡 胶 中 涂 /面 漆 的 用 途 Specification and Surface preparation技术要求及表面处理Iron: Crit blasted to Swedish Standard Sa2.5 SIS055900. steel precoated with primer( precoated in factory)
6、: With ratary power discing , rubdown small-size rusty part. Clear all of the soluble salt. Smooth rusty edge If the rusty area ia large, completely sanding should be done , the surface over precoated primer must be clean and dry. Romve dirt with hard bristly brush and diposited should be salt by wa
7、ter. Other surface (such as gypsum,cement):the substrate surface over appropriate primer must be clean, dry and free from dirt before paiting.铁：喷砂清洁至 Sa2.5 瑞典标准 SIS055900。 预涂底漆钢材（在场内预涂）以动力转盘打磨小面积的生锈部分，洗除所有的可溶盐份，并磨平生锈边缘，如果生锈面积大，需全面扫砂，已预涂刚才，底漆表面必须清洁（如石膏、水泥等：可复涂於有适当涂装底漆的其他底材上，但漆表面必须清洁、干燥、无污物。Limitation
8、s限制Unable to resist solvent,grease or fat.It is themoplastic apt to soften and decompose above 80 摄氏度。不耐溶剂，油脂和脂肪，热塑性。在 80 摄氏度以上易倾向软化和分解。 SafetyPrecautions安全措施This product should be used in painting area by perfessional operators. When painting , please refer to Product Data Sheet and MSDS. Consult o
9、ur company if consumers could not completely understand the precautions for safety and health when applying this product.This product is a kind of solvent-based paint .Inorder to avoid danger or accident, minimal safety precautions,as follow , should be down .The paint contains volatile solvent and
10、is flammable . So must keep away from sparks and open flames.No smoking at applacation site ,Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid producting sparks .Flash point of pai
11、nt , mentioned above on product Data sheet, is the lowest temperature at which mixture of the volatile materails of paint can ignite or explode with air. Enough ventilation is necessary at application site. In order to remove any danger of explosion, must keep the ratio of gas to air is less than 10
12、%, the minimum explosive limit in general, Therefore, 200m3 of ventilation quantuty per 1Kg solvent (according to the solvent ) is necessary.Product skin and eyes, and avoid touching with paints (Recommend to wear working clothes, gloves,eye protection, face masks barrier cream and so on ). Kif pain
13、t gets in touch with skin , wass fully with large amount of fresh water and soap or appropriate commercial cleaner. In case of eyes being contaminated, rinse with fresh water for 10min at least and give medical treatment immediately. Recommend face guard with ventilation pipe for the sake of no abso
14、rption of paint fog and harmful solvent gas, especially in bad ventilation.Handle empty containers with care and do not bring about environmental contamination.NOTICE: If consumers have not taken effective safety precautions(Refer to the specfications), our company will NOTbe responsible for any accident.本产品由专业人缘在工业场所使用,使用时请参照本说明书及健康安全手册,如客户在使用本产品前,未能仔细了解有关产品的健康安全知识,请与本公司联系.该涂料为溶剂型涂料,为避免事故或危险发生,应采取最低限度的安全措施如下:此涂料为易燃物,并含有挥发性易燃溶剂,故必须远离火星和明火,严禁在作业场所吸烟,并采取有效措施,防止火星产生(如采用防爆电器设备 ,杜绝静电积累,避免金属撞击等) 本产品说明书中所列涂料及溶剂的闪点是引起燃烧的最低温度. 施工场所应尽量进行通风良好,为消除使用过程中的爆炸隐患,应保证足够的通风量以维持气体/空气比
